LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1263 (Body Rear End) >> Repair Instructions >> Lock Replacement - Rear Door (E54) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2002 GMC Safari and 2002 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
  2. Separate the water deflector at the perforations. Use a sharp-bladed tool if needed. Refer to Water Deflector Replacement  .
  3. Remove the control rods from the lock assembly.
    1. Pry the clip anchor out of the hole.
    2. Push the clip away from the lever.
    3. Pull the rod and the clip away from the lever.
  4. Remove the screws that retain the lock to the door.
  5. Remove the lock from the door.
    6. Fig 1: Removing & Installing Rear Door (E54) Lock Assembly
    G02507159Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals