LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1261 (Engine Exhaust System) >> Repair Instructions >> Muffler Replacement (4.8L and 5.3L Engines) >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2002 GMC Yukon XL, 2002 GMC Yukon, 2002 Chevrolet Tahoe, 2002 Chevrolet Suburban, and 2002 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View of Oil Pan Skid Plate
    GM339429Courtesy of GENERAL MOTORS CORP.
  1. Remove the rear tires and wheels. Refer to TIRE AND WHEEL REMOVAL AND INSTALLATION .
  2. Remove the oil pan skid plate bolts and plate, if necessary.
  3. Remove the spare tire.
  4. Fig 2: Identifying Electronic Suspension Rear Position Sensor & Rear Shock
    GM665311Courtesy of GENERAL MOTORS CORP.
  5. If servicing a vehicle equipped with regular production option (RPO) Z55, disconnect the chassis harness from the following electrical connectors:
    • Electronic suspension rear position sensor (1)
    • Rear shock (2)
  6. IMPORTANT: Do not attempt to pry the rear suspension sensor link rod from the rear position sensor ball stud.
  7. Remove the left and right sensor link rods from the sensors, perform the following:
    1. Support the sensor lever with your hand
    2. Twist the link rod in order to remove it from the ball stud
  8. Install adjustable jack stands under the rear axle.
  9. Fig 3: View of Rear Axle Vent Hose
    GM692548Courtesy of GENERAL MOTORS CORP.
  10. Remove the rear axle vent hose from the rear axle, if necessary.
  11. Remove the vent hose swivel clip from the rear brake crossover pipe.
  12. Fig 4: Identifying Rear Shock Absorbers
    GM665315Courtesy of GENERAL MOTORS CORP.
  13. Remove the rear shock absorbers lower bolts and nuts.
  14. Lower the rear axle slightly, using the adjustable jack stands, in order to remove the muffler.
  15. Fig 5: Identifying Exhaust Muffler Nuts
    GM664840Courtesy of GENERAL MOTORS CORP.
  16. Remove the exhaust muffler nuts.
  17. Fig 6: View of Muffler
    GM665327Courtesy of GENERAL MOTORS CORP.
  18. Remove the muffler from the insulators.