LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1115 (Sunroof System) >> Repair Instructions >> Sunroof Window Height and Opening Fit Adjustment

Sunroof Window Height and Opening Fit Adjustment

WARNING: This page is about a different car, the 2004 Pontiac Aztek and 2004 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
  1. Slide the sunroof sunshade to the open position.
  2. Adjust the sunroof glass panel to the fully closed position.
  3. Separately loosen the 6 sunroof glass panel screws (3 each side).
    Fig 1: Illustrating Sunroof Window Adjustment Locations
    GM741356Courtesy of GENERAL MOTORS CORP.
  4. Individually adjust the 4 corners of the sunroof glass panel.
  5. Adjust the front of the sunroof glass panel to 2.0 mm (0.079 in) below the top surface of the roof panel.
  6. Adjust the rear of the sunroof glass panel to 2 mm (1/8 in) above the top surface of the roof panel.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  7. Tighten the sunroof glass panel screws.

    Tighten:  Tighten the sunroof glass panel screws to 4 N.m (35 lb in).

scientia non olet · About LEMON Manuals