LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1105 (Parking Brake System) >> Diagnostic Information and Procedures >> Park Brake Shoe Inspection

Park Brake Shoe Inspection

WARNING: This page is about a different car, the 2004 Pontiac Aztek and 2004 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Refer to Brake Dust Caution in Cautions and Notices.
    Fig 1: Identifying Rear Brake Components
    GM177186Courtesy of GENERAL MOTORS CORP.
  1. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle in General Information.
  2. Remove the tire and wheel. Refer to Tire and Wheel Removal and Installation in Tires and Wheels.
  3. Remove the rear brake caliper bracket with the rear brake caliper. Refer to Brake Caliper Bracket Replacement - Rear in Disc Brakes.
  4. Remove the rear brake rotor. Refer to Brake Rotor Replacement - Rear in Disc Brakes.

  5. Inspect the park brake shoe and lining. If it exhibits any of the following conditions, then it requires replacement :
    • Excessive wear indicated by the park brake lining being worn down to the shoe
    • Brake lining cracking
    • Oil or fluid contamination of the brake lining
  6. Install the rear brake rotor. Refer to Brake Rotor Replacement - Rear in Disc Brakes.
  7. Install the rear brake caliper with the rear brake caliper bracket. Refer to Brake Caliper Bracket Replacement - Rear in Disc Brakes.
  8. Install the tire and wheel. Refer to Tire and Wheel Removal and Installation in Tires and Wheels.
  9. Lower the vehicle.
scientia non olet · About LEMON Manuals