LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1059 (Lighting Systems) >> Repair Instructions >> Headlamp Assembly or Headlamp Bulb Replacement (Rendezvous) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Pontiac Aztek and 2004 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
    CAUTION: Refer to Halogen Bulb Caution in Cautions and Notices.
  1. Open the hood.
  2. Remove the thumb screw from the back of the headlamp.
    3. Fig 1: Locating Headlamp Retainer
    GM761252Courtesy of GENERAL MOTORS CORP.
  3. Release the headlamp retainer by lifting up.
    4. Fig 2: View Of Headlamp
    GM755085Courtesy of GENERAL MOTORS CORP.
  4. Pull the headlamp straight forward, to release the ball stud from the grommet.
  5. Remove the headlamp from the upper fascia support.
  6. Disconnect the electrical connector from the headlamp.
    7. Fig 3: Identifying Headlamp Bulb
    GM761255Courtesy of GENERAL MOTORS CORP.
  7. Remove the bulb(s) from the headlamp by rotating counterclockwise.
    8. Fig 4: Locating Headlamp Trim Tabs
    GM761257Courtesy of GENERAL MOTORS CORP.
  8. Release the headlamp trim tabs from the headlamp, if required.
    9. Fig 5: View Of Headlamp Trim
    GM761253Courtesy of GENERAL MOTORS CORP.
  9. Remove the headlamp trim from the headlamp, pulling to release the adhesive tape.
  10. Clean adhesive from the headlamp trim and headlamp using 3M™ adhesive remover P/N 8984, or equivalent.
scientia non olet · About LEMON Manuals