LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1020 (Propeller Shaft And Universal Joints) >> Diagnostic Information and Procedures >> Leak at Front Slip Yoke

Leak at Front Slip Yoke

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
Leak at Front Slip Yoke

Checks Action
DEFINITION: An occasional drop of lubricant leaking from the splined yoke is normal and requires no attention.
The slip yoke barrel is burred, nicked, corroded, or worn.
  1. Inspect the slip yoke for burrs.

    Minor burrs can be removed by careful use of crocus cloth or fine stone honing.

  2. If the is badly burred, corroded or worn, replace the yoke. Refer to Propeller Shaft Replacement - One Piece  or Propeller Shaft Replacement - Two Piece .
  3. Replace the oil seal. Refer to one of the following:
There is a faulty transmission or transfer case output shaft oil seal. Replace the oil seal. Refer to one of the following:
scientia non olet · About LEMON Manuals