LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> Body Rear End >> Repair Instructions >> Door Replacement - Rear (Cargo Doors) >> Removal Procedure

Removal Procedure

  1. Remove the trim panel. Refer to TRIM PANEL REPLACEMENT - REAR DOOR (CARGO DOORS)  or TRIM PANEL REPLACEMENT - REAR DOOR (E54)  .
  2. Remove the water deflector from the door. Refer to WATER DEFLECTOR REPLACEMENT - SLIDING DOOR .
  3. On the right door, remove the wiring harness from the license plate lamp and the power lock actuator, if equipped.
  4. Remove the harness and the conduit from the right door.
  5. Remove the stereo speakers, if equipped. Refer to SPEAKER REPLACEMENT - REAR DOOR in Entertainment.
  6. Remove the check link. Refer to CHECK LINK REPLACEMENT - REAR DOOR (CARGO DOOR)  or CHECK LINK REPLACEMENT - REAR DOOR (E54)  .
  7. Drive the hinge pins (3) from the hinges (2) while an assistant holds the door in place.
  8. With an assistant, remove the door from the vehicle.
    Fig 1: Removing Door Hinge Pins - Rear (Cargo Doors)
    G01567312Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals