Brake Shoes &/Or Pads: Remove & Replace
WARNING: This page is about the Magnavan 5.7 K, 400/M40, which is a different variant/trim than selected.
Includes: Clean, lube and/or replace Brake Hardware as necessary. Adjust Brakes (where applicable).
Includes: Repack Wheel Bearings (where applicable).
DOES NOT include refinishing.| Applies To | Note | Standard Hours | Warranty Hours | Skill Level |
|---|---|---|---|---|
| G3500, All,Full Floating Axle | 2.8 | B | ||
| G3500, All,Semi-Floating Axle | 2.2 | B | ||
| G3500, Front | 1.0 | 0.9 | B | |
| G3500, Rear,Full Floating Axle | 2.0 | 1.7 | B | |
| G3500, Rear,Semi-Floating Axle | 1.4 | 0.9 | B | |
| Combination Procedure: AXLE BEARING: Replace: | ||||
| G3500, Rear,Full Floating Axle,Each | Includes: Repack Wheel Bearings. | 0.1 | B | |
| G3500, Rear,Semi-Floating Axle,Both | 0.8 | B | ||
| G3500, Rear,Semi-Floating Axle,One Side | 0.6 | B | ||
| Combination Procedure: AXLE SEAL: Replace: Semi-Floating Axle. | ||||
| Rear,Both | 0.8 | B | ||
| Rear,One Side | 0.6 | B | ||
| Combination Procedure: BRAKE HOSE: Replace: | ||||
| w/o ABS,Each Additional | Includes: Bleed Brakes. | 0.2 | B | |
| w/o ABS,One | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: CALIPER: Overhaul: | ||||
| G3500, One,Front,Dual Piston,w/o ABS | Includes: Bleed Brakes. | 0.7 | B | |
| G3500, One,Front,Single Piston,w/o ABS | Includes: Bleed Brakes. | 0.5 | B | |
| Combination Procedure: CALIPER: Replace: | ||||
| One,w/ABS,2-Wheel ABS | Includes: Bleed Brakes. | 0.9 | B | |
| One,w/o ABS | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: DISC ROTOR: Burnish Brake Rotors While Driving Vehicle: | ||||
| 0.5 | B | |||
| Combination Procedure: DISC ROTOR: Remove and Install for Refinishing: | ||||
| RWD, Each | Includes: Repack Wheel Bearings. | 0.4 | B | |
| Combination Procedure: DISC ROTOR: Replace: | ||||
| Each,Non Separable | Includes: Repack Wheel Bearings. | 0.4 | B | |
| Each,Separable | Includes: Repack Wheel Bearings. | 0.5 | B | |
| Combination Procedure: DRUM: Replace: | ||||
| Each,Inboard Mounted,Separable | 0.3 | B | ||
| Each,Outboard Mounted,Separable | 0.1 | B | ||
| Combination Procedure: WHEEL BEARING: Repack: Both Sides. | ||||
| RWD, Front | 0.8 | B | ||
| Combination Procedure: WHEEL BEARING: Replace: | ||||
| RWD, Front,One Side | Includes: Repack Wheel Bearings. | 0.5 | B | |
| Combination Procedure: WHEEL CYLINDER: Overhaul: | ||||
| w/o ABS,One,Off Vehicle | Includes: Bleed Brakes. | 0.5 | B | |
| w/o ABS,One,On Vehicle | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: WHEEL CYLINDER: Replace: | ||||
| w/o ABS,One | Includes: Bleed Brakes. | 0.3 | B | |