LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2022 >> Transit Connect Titanium, Gas/Ethanol >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Climate Control System - General Information (2 Of 2) >> Diagnosis And Testing >> Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) >> Symptom Charts >> Symptom Chart - NVH

Symptom Chart - NVH

Diagnostics in this article assume a certain skill level and knowledge of Ford-specific diagnostic practices. REFER to: Diagnostic Methods .

Condition Possible Sources Actions
Excessive hissing from the plenum when the A/C is on Low refrigerant charge INSPECT the A/C system for a leak. REFER to the appropriate GENERAL PROCEDURES .
The A/C compressor is noisy A/C compressor clutch air gap out of specification CHECK and ADJUST the A/C compressor clutch gap if necessary. REFER to the appropriate GENERAL PROCEDURES .
If the A/C compressor clutch air gap is OK, INSTALL a new A/C compressor clutch and field coil. REFER to the appropriate GENERAL PROCEDURES .
A/C compressor pulley bearing worn INSPECT the A/C compressor pulley bearing for roughness.
If pulley bearing roughness is found, INSTALL a new A/C compressor pulley. REFER to the appropriate REMOVAL AND INSTALLATION .
A/C compressor bearing worn INSPECT the A/C compressor bearing for roughness. If bearing roughness is found, INSTALL a new A/C compressor. REFER to the appropriate REMOVAL AND INSTALLATION .
scientia non olet · About LEMON Manuals