Chart 8
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2022 Ford F-550 Super Duty, 2022 Ford F-450 Super Duty, 2022 Ford F-350 Super Duty, 2022 Ford F-250 Super Duty, and 2021 Ford F-550 Super Duty. However, it is still accessible from the selected car via links, so may be relevant.
- Exhaust System Concerns: Visible Smoke (No Oil Consumption)
| SYSTEM OR COMPONENT | REFERENCE (Engine Controls Pinpoint Test unless noted) |
|---|---|
| Fuel Quality | REFER to DIAGNOSTIC PROCEDURES , Sufficient Clean Fuel. |
| Black Exhaust Smoke | CHECK for charge air cooler (CAC) restrictions. |
| White Exhaust Smoke | Some white exhaust smoke is a normal condition at start up with temperatures below 10°C (50°F) or with an extended idle in a cool climate. GO to PINPOINT TEST AF . |
| Charge Air Cooler (CAC) For Restrictions | CHECK for any conditions that may restrict airflow through the CAC. DISCONNECT the tubes at the CAC and CHECK for restrictions. CHECK inside of the CAC for restrictions. If there are any restrictions, REPAIR as necessary. |
| Engine Coolant Leak | REFER to the Engine Cooling, Component Tests, Engine Cooling System Pressure Test. |
| Thermostat Operation | REFER to the Engine Cooling, Component Tests, Thermostat. |
| Engine Compression | REFER to the Engine, General Procedures, Compression Test. |
| Exhaust Gas Recirculation (EGR) System | GO to PINPOINT TEST W . |
| Mass Airflow (MAF) Sensor | GO to PINPOINT TEST J . |
| Cylinder Compression | REFER to the Engine, General Procedures, Compression Test. CARRY OUT the Compression Test. |