P0442 - EVAP System Leak Detected (Small Leak)

WARNING: This page does not describe the selected car, but rather 27 other vehicles, including the 2021 Lincoln Navigator, 2021 Lincoln Nautilus, 2021 Lincoln Corsair, 2021 Lincoln Aviator, and 2021 Ford Transit-350 HD. However, it is still accessible from the selected car via links, so may be relevant.

DTC DESCRIPTION P0442 - EVAP SYSTEM LEAK DETECTED (SMALL LEAK)

Description:	This DTC sets when a small fuel vapor leak is detected by the EVAP running loss monitor test.
Possible Causes:	Aftermarket EVAP hardware that does not conform to the required specifications Small holes or cuts in the fuel vapor hoses or tubes EVAP canister vent valve stays partially open on closed command Damaged, missing or loosely installed fuel filler cap (if equipped) Capless fuel tank filler pipe damaged or not sealed correctly (if equipped) Loose fuel vapor hose or tube connections to the EVAP system components EVAP system component seals leaking at or near the EVAP purge valve, fuel tank pressure (FTP) sensor, EVAP canister vent valve, fuel vapor control valve tube assembly or fuel vapor vent valve assembly
Diagnostic Aids:	Check for a missing fuel filler cap or the integrity of the cap (if equipped). Verify the capless fuel tank filler pipe is sealed correctly (if equipped). Install and remove the supplemental fueling adapter five times in the capless fuel tank filler pipe to clear debris on the seal. Refer to the Owner Literature for the location of the supplemental fueling adapter in the vehicle. Check for loose or damaged vapor hoses. Visually inspect the EVAP canister inlet port, EVAP canister vent valve filter, and canister vent hose assembly for contamination or debris.
Application	Key On Engine Off	Key On Engine Running	Continuous Memory
All	GO to Pinpoint Test HX.