Symptom Chart: Symptom Chart - Exhaust System

WARNING: This page is about a different car, the 2019 Ford F-350 Super Duty and 2019 Ford F-250 Super Duty. However, it is still accessible from the selected car via links, so may be relevant.

Verify the customer concern. Inspect the components of the exhaust system for obvious signs of damage or other mechanical concerns using the following chart.

Visual Inspection Chart - Mechanical

Mechanical
Exhaust pipe pinched or crushed Damaged muffler Broken or damaged exhaust hanger brackets Damaged catalytic converters Loose or damaged heat shields

Verify the exhaust system is installed correctly, with clamps correctly located and tightened to specifications. If the fault is not visually evident, determine the symptom. GO to Symptom Chart below.

Symptom Chart

Condition	Possible Sources	Actions
Vehicle has low or no power -- vehicle performance complaint	Exhaust pipe pinched or crushed Damaged catalytic converter Loose obstruction in exhaust	REFER to Engine Controls - Symptom Charts (Except Diesel & Hybrid) .
	Restricted exhaust (possible frozen condensate in muffler)	CHECK drain holes for foreign material. PARK the vehicle inside to thaw. TEST the vehicle for normal operation. If the concern is still present, REFER to Engine Controls - Symptom Charts (Except Diesel & Hybrid) .
Burning smell -- usually occurs at idle, with possible traces of smoke	Foreign material caught in exhaust system Missing heat shields	INSPECT the exhaust system for foreign material or missing heat shields. REPAIR or INSTALL new components as necessary.
Odor -- described as a sulfur or rotten egg smell	Catalytic converter Excessive sulfur content in fuel	At times, a slight sulfur smell is normal for catalytic converters. The cause is the sulfur content in the gasoline being used. ADVISE the customer no repair is required.
Odor -- described as a sulfur or rotten egg smell	Rich fuel conditions Misfire conditions	REFER to Engine Controls - Symptom Charts (Except Diesel & Hybrid) .
Visible rust on surface of exhaust pipes	Catalytic converter/exhaust system	Surface rust is a characteristic of materials used on exhaust systems. Exposure to heat or road salt may result in surface rust. INSPECT for perforations. If there are no perforations, the condition is normal.