Pinpoint Test E : The Power Lumbar Is Inoperative -- Passenger, Without Multi-Contour Seats

WARNING: This page is about a different car, the 2020 Ford F-150. However, it is still accessible from the selected car via links, so may be relevant.

WARNING: Incorrect repair techniques or actions can cause an accidental Supplemental Restraint System (SRS) deployment. Never compromise or depart from these instructions. Failure to precisely follow all instructions could result in serious personal injury from an accidental deployment.

E1 CHECK FOR VOLTAGE TO THE SEAT LUMBAR MOTOR

REFER to: Supplemental Restraint System (SRS) Depowering .

Disconnect: Passenger Side Airbag In-line C3053.

Disconnect: Passenger Seat Lumbar Motor C3216.

NOTE: The voltage being measured changes polarity depending upon which direction the seat control switch is activated.

While pushing the lumbar switch in both directions, measure:

Positive Lead	Measurement / Action	Negative Lead
C3216-A	Courtesy of FORD MOTOR COMPANY	C3216-B

Is the voltage greater than 11 volts when the seat control switch is operated in both directions?

Yes	INSTALL a new passenger seat power lumbar assembly. REFER to: Front Seat Lumbar Assembly . GO to E3

GO to E2

E2 CHECK THE SEAT LUMBAR MOTOR CIRCUITS FOR AN OPEN

Disconnect: Passenger Seat Control Switch C3388.

Measure:

Positive Lead	Measurement / Action	Negative Lead
C3388-20	Courtesy of FORD MOTOR COMPANY	C3216-B
C3388-2	Courtesy of FORD MOTOR COMPANY	C3216-A

Are the resistances less than 3 ohms?

Yes	INSTALL a new passenger seat control switch. REFER to: Front Seat Control Switch . GO to E3

No	REPAIR the circuit in question. GO to E3

E3 VERIFY THE SRS (SUPPLEMENTAL RESTRAINT SYSTEM) PROVES OUT SUCCESSFULLY

REFER to: Supplemental Restraint System (SRS) Depowering .

Connect: Passenger Side Airbag In-line C3053.

Connect all previously disconnected connectors.

REFER to: Supplemental Restraint System (SRS) Repowering .

Did the SRS prove out successfully?

Yes	Repair is complete. RETURN the vehicle to the customer.

No	For Raptor and Phantom, REFER to: Airbag Supplemental Restraint System (SRS) . For all except Raptor and Phantom, REFER to: Airbag Supplemental Restraint System (SRS) .