Battery and Battery Charging Health and Safety Precautions

WARNING: This page is about a different car, the 2018 Ford Fiesta. However, it is still accessible from the selected car via links, so may be relevant.

WARNING: Batteries contain sulfuric acid and produce explosive gases. Work in a well-ventilated area. Do not allow the battery to come in contact with flames, sparks or burning substances. Avoid contact with skin, eyes or clothing. Shield eyes when working near the battery to protect against possible splashing of acid solution. In case of acid contact with skin or eyes, flush immediately with water for a minimum of 15 minutes, then get prompt medical attention. If acid is swallowed, call a physician immediately. Failure to follow these instructions may result in serious personal injury.

WARNING: Always lift a plastic-cased battery with a battery carrier or with hands on opposite corners. Excessive pressure on the battery end walls may cause acid to flow through the vent caps, resulting in personal injury and/or damage to the vehicle or battery.

WARNING: Battery posts, terminals and related accessories contain lead and lead components. Wash hands after handling. Failure to follow these instructions may result in serious personal injury.

Li-ion Batteries:

WARNING: Explosion and fire hazard. The terminals of the Li-ion Battery are always live. Do not place items or tools on the Li-ion Battery. Avoid short circuits and excessive discharge/charge rates. Use insulated tools only. Do not wear any metallic items such as watches, bracelets or rings. Failure to follow these instructions may result in a fire or serious personal injury.

WARNING: Never try to open or disassemble the Li-ion Battery. Electrolyte is very corrosive. Under normal working conditions, contact with the electrolyte is not possible. If the battery case is damaged, do not touch exposed electrolyte or powder. Failure to follow these instructions may result in serious personal injury.

WARNING: Batteries contain sulphuric acid, avoid contact with skin, eyes or clothing. Wear safety goggles when working near the battery to protect against possible splashing of the acid solution.

WARNING: EYE CONTACT: If acid comes into contact with the eyes, flush immediately with plenty of running water for a minimum of 15 minutes. Seek immediate medical attention.

WARNING: SKIN CONTACT: If acid comes into contact with the skin, flush immediately with plenty of running water for a minimum of 15 minutes. Seek immediate medical attention.

WARNING: SWALLOWED: If acid is swallowed, rinse the mouth with plenty of water and then drink plenty of water or milk. Do not induce vomiting. Seek immediate medical attention.

WARNING: Batteries normally produce explosive gases. Do not allow naked flames, sparks or lighted substances to come near the battery.

WARNING: When charging the battery shield your face and wear safety goggles. Provide adequate ventilation.

NOTE: Boost charging with excessive current or voltage above 16 volts will damage the battery.