LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2017 >> Transit Connect XLT, Van Passenger >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Climate Control System - General Information >> Diagnosis And Testing >> Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) >> Symptom Charts >> Symptom Chart - NVH

Symptom Chart - NVH

Diagnostics in this article assume a certain skill level and knowledge of Ford-specific diagnostic practices. Refer to: Diagnostic Methods .

Symptom Chart 

Condition Possible Sources Actions
Excessive hissing from the plenum when the A/C is on Low refrigerant charge INSPECT the A/C system for a leak. Refer to: Electronic Leak Detection . Refer to: Fluorescent Dye Leak Detection . Refer to: Air Conditioning (A/C) System Recovery, Evacuation and Charging .
The A/C compressor is noisy A/C compressor clutch air gap out of specification CHECK and ADJUST the A/C compressor clutch gap if necessary. Refer to: Air Conditioning (A/C) Clutch Air Gap Adjustment .
If the A/C compressor clutch air gap is OK, INSTALL a new A/C compressor clutch and field coil. Refer to: Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil .
A/C compressor pulley bearing worn INSPECT the A/C compressor pulley bearing for roughness.
If pulley bearing roughness is found, INSTALL a new A/C compressor pulley. Refer to: Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil .
A/C compressor bearing worn INSPECT the A/C compressor bearing for roughness. If bearing roughness is found, INSTALL a new A/C compressor. Refer to: Air Conditioning (A/C) Compressor - 2.5L Duratec (125kW/170PS) .
scientia non olet · About LEMON Manuals