Symptom Chart
WARNING: This page is about a different variant/trim than selected.
Diagnostics in this article assume a certain skill level and knowledge of Ford-specific diagnostic practices. Refer to: Diagnostic Methods .
| Condition | Possible Sources | Actions |
|---|---|---|
| Clutch slippage | Clutch pedal reserve Worn or damaged pressure plate Clutch disc facing Hardened or oiled clutch disc facing surface Flywheel |
GO to Pinpoint Test A |
| Clutch chatter, rattle or shudder | Loose or damaged engine or transmission mounts Oil on clutch disc facing Worn pressure plate Clutch disc facing Loose or damaged flywheel Worn clutch disc |
GO to Pinpoint Test B |
| Clutch drag | Insufficient clutch hydraulic fluid Air in hydraulic system Clutch pedal reserve Diaphragm springs Clutch disc Clutch disc splines Oil on clutch disc facing |
GO to Pinpoint Test C |
| Clutch pedal pulsation | Clutch and brake pedal pivot shaft not correctly lubricated Flywheel Worn pressure plate springs |
GO to Pinpoint Test B |
| Clutch related vibrations | Engine component grounding against frame Accessory drive belt Flywheel bolts loose Flywheel Imbalanced clutch pressure plate |
GO to Pinpoint Test B |
| Hard shifting | Insufficient clutch hydraulic fluid Clutch pedal reserve Transmission concern |
GO to Pinpoint Test C |
| Clutch system leakage | Clutch master cylinder Clutch slave cylinder Clutch hydraulic tubes |
INSPECT the clutch master cylinder, the clutch slave cylinder and all hydraulic system tubes for leakage. REPAIR as necessary. |
| Clutch pedal falls to floor/clutch does not disengage | Air in hydraulic system Excessive crankshaft end play Slave cylinder/Master cylinder |
Bleed clutch hydraulic system. Refer to: Clutch System Bleeding . Measure the crankshaft end play. Refer to: Engine . INSPECT the clutch master cylinder, the clutch slave cylinder and all hydraulic system tubes for leakage, or damage. REPAIR as necessary. |