LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2016 >> Fusion Titanium, AWD >> Repair and Diagnosis (Single Page) >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Sunroof - Roof Opening Panel (Except Hybrid) >> Removal And Installation >> Roof Opening Panel Frame >> Removal

Roof Opening Panel Frame: Removal

NOTE: Removal steps in this procedure may contain installation details.

  1. 1.

    If replacing the roof opening panel frame, remove the air deflector. REFER to: Air Deflector .

  1. 2.

    Fully close the roof opening panel glass.

  1. 3.

    Remove the roof opening panel glass. REFER to: Roof Opening Panel Glass .

  1. 4.

    On both sides, remove the A-pillar trim panel. REFER to: A-Pillar Trim Panel .

  1. 5.

    On both sides, remove the B-pillar trim panel. REFER to: B-Pillar Trim Panel .

  1. 6.

    On both sides, remove the C-pillar upper trim panel. REFER to: C-Pillar Upper Trim Panel .

  1. 7.

    Remove the passenger seat head restraint, position the passenger seat in the full rearward and full reclined position.
GFD69840Courtesy of FORD MOTOR COMPANY

  1. 8.

    Position the driver seat in the full forward and full reclined position.
GFD69841Courtesy of FORD MOTOR COMPANY

  1. 9.

    If equipped.

    1. 1.

      Release the upper rear view mirror cover clips.

    1. 2.

      Remove the upper rear view mirror cover.
GFD69842Courtesy of FORD MOTOR COMPANY

  1. 10.

    If equipped.

    1. 1.

      Release the lower rear view mirror cover clips by squeezing on the sides.

    1. 2.

      Remove the lower rear view mirror cover.
GFD69843Courtesy of FORD MOTOR COMPANY

  1. 11.

    If equipped. Disconnect the rear view mirror electrical connectors.
GFD69375Courtesy of FORD MOTOR COMPANY

  1. 12.

    On both sides. Remove the sun visors.

    1. 1.

      Remove the retainer cap.

    1. 2.

      Release the clip.

    1. 3.

      Remove the sun visor.

    1. 4.

      If equipped. Disconnect the electrical connector.
GFD69844Courtesy of FORD MOTOR COMPANY

  1. 13.

    On both sides. Remove the retainer and the sun visor clip.
GFD69845Courtesy of FORD MOTOR COMPANY

  1. 14.

    NOTE: LH side shown in illustration, RH side similar.

    On both sides. Remove the retainer covers, the retainers and the grab handle.

GFD69846Courtesy of FORD MOTOR COMPANY

  1. 15.

    On both sides. Detach the wire harness retainers.
GFD69847Courtesy of FORD MOTOR COMPANY

  1. 16.

    NOTE: When releasing the magnets around the roof opening panel area, pull down on the plastic headliner reinforcement between the headliner and the roof or damage to the headliner may result.

    Carefully release the seven magnets and two guide pins and magnets.

GFD69470Courtesy of FORD MOTOR COMPANY

  1. 17.

    Position the headliner as shown in illustration.
GFD69848Courtesy of FORD MOTOR COMPANY

  1. 18.

    Disconnect the roof opening panel drain hoses from the corners of the roof opening panel frame.
GFD69849Courtesy of FORD MOTOR COMPANY

  1. 19.

    With the help of an assistant. Disconnect the roof opening panel motor electrical connector, remove the roof opening panel frame bolts.

    Torque

    : 106 lb.in (12 Nm)

GFD69850Courtesy of FORD MOTOR COMPANY

  1. 20.

    With the help of an assistant. Remove the roof opening panel frame.
GFD69851Courtesy of FORD MOTOR COMPANY
scientia non olet · About LEMON Manuals