LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2012 >> Explorer Base, 3.5 8, AWD, 6F50 >> Repair and Diagnosis >> External Pages >> Different car >> Section 24 (Engine Mechanical - 6.7L Diesel) >> Specifications >> Torque Specifications

Torque Specifications

WARNING: This page is about a different car, the 2013 Ford F-550 Super Duty, 2013 Ford F-450 Super Duty, 2013 Ford F-350 Super Duty, and 2013 Ford F-250 Super Duty. However, it is still accessible from the selected car via links, so may be relevant.
Description Nm lb-ft lb-in
A/C compressor bolts 25 18 -
Accessory drive belt idler pulley bracket bolts (non-A/C vehicles) 25 18 -
Accessory drive belt idler pulley bolt 48 35 -
Accessory drive belt tensioner bolt 48 35 -
Air Cleaner (ACL) outlet pipe clamp 4 - 35
Block heater 41 30 -
Body bolts 90 66 -
Camshaft gear bolt(1) - - -
Camshaft Position (CMP) sensor bolt 10 - 89
Camshaft thrust plate bolts 25 18 -
Charge Air Cooler (CAC) tube clamp nut 9 - 80
CAC bolts 12 - 106
Connecting rod cap bolts (1) - - -
Coolant crossover manifold assembly bolts 10 - 89
Coolant inlet connector fitting 40 30 -
Cooling fan clutch electrical connector bolt 25 18 -
Cooling fan clutch hub nut(1) - - -
Cooling fan drive assembly bolts 24 18 -
Cooling fan stator nuts 17 - 150
Cooling fan stator stand offs 22 16 -
Crankcase vent oil separator bolts 10 - 89
Crankcase vent oil separator stud bolts 10 - 89
Crankshaft main bearing cap bolts (1) - - -
Crankshaft main bearing cap side bolts (1) - - -
Crankshaft Position (CKP) sensor bolt 10 - 89
Crankshaft pulley bolts (1) - - -
Cylinder head bolts (M8) (1) - - -
Cylinder head bolts (M12) (1) - - -
EGR cooler assembly bolts (1) - - -
EGR valve inlet tube bolts (1) - - -
EGR bypass outlet tube bolts 10 - 89
EGR valve inlet tube bracket bolts (1) - - -
EGR valve vacuum regulator bolt 5 - 44
Engine Coolant Temperature (ECT) sensor 27 - 20
Engine front cover bolts (1) - - -
Engine support insulator cross bolts 350 258 -
Engine support insulator nuts - LH 200 148 -
Engine support insulator nuts - RH 115 85 -
Engine support insulator bracket bolts (1) - - -
Engine support insulator studs 80 59 -
Engine Oil Pressure (EOP) switch 20 - 177
Engine Oil Temperature (EOT) sensor 20 - 177
Engine rear cover bolts (M6) (1) - - -
Engine rear cover bolt (M10) (1) - - -
Engine wire harness bolt 10 - 89
Engine wire harness bracket bolt at frame 25 18 -
Engine wire harness ground bolt at frame 25 18 -
Engine wire harness nuts at upper oil pan 12 - 106
Evaporator-to-compressor suction hose fitting nut 15 - 133
Exhaust Gas Recirculation Temperature (EGRT) sensor - outlet 44 32 -
Exhaust manifold heat shield bolts 10 - 89
Exhaust manifold nuts (1) - - -
Exhaust manifold studs 13 - 115
Exhaust manifold flange nuts 25 18 -
Exhaust manifold flange studs 13 - 115
Exhaust Pressure (EP) sensor mounting nut (1) - - -
EP sensor tube nut (1) - - -
Flexplate mounting bolts (1) - - -
Front End Accessory Drive (FEAD) mounting bolts 24 18 -
Fuel injector hold-down bolts (1) - - -
Fuel injector supply tubes (1) - - -
Fuel injection pump supply tube bolt and stud bolt 10 - 89
Fuel rail bolts (1) - - -
Fuel rail supply tube bracket bolts 10 - 89
Fuel supply tube assembly bolt and stud bolt(1) - - -
Fuel supply tube assembly connector (1) - - -
Generator B+ terminal nut 17 - 150
Generator mounting bolt 48 35 -
Glow plug 11 - 97
Ground strap bolt 10 - 89
Heater supply tube bolts 10 - 89
High-pressure fuel injection pump drive gear nut 80 59 -
High-pressure fuel injection pump mounting bolts 48 35 -
High-pressure fuel injection pump spacers 24 18 -
High-pressure fuel injection pump supply tube retainer nut 11 - 97
LH battery tray bolts 18 - 159
Lower engine wire harness bolts 12 - 108
Lower engine wire harness nuts 12 - 108
Lower intake manifold bolts 24 18 -
Manifold Absolute Pressure (MAP) sensor 5 - 44
Oil cooler bolts (1) - - -
Oil cooler nut (1) - - -
Oil filter adapter bolts 10 - 89
Oil filter adapter stud bolt 10 - 89
Oil level indicator tube bolt 10 - 89
Oil fill pipe bolt 10 - 89
Oil pan baffle bolts(1) - - -
Oil pan bolts - lower (1) - - -
Oil pan bolts - upper(1) - - -
Oil pan drain plug 26 19 -
Oil pump screen and pick-up tube bolts 10 - 89
Oil spray bar nuts (1) - - -
PCM nuts 7 - 62
Piston cooling tube bolts 10 - 89
Positive battery cable clamp nut 7 - 62
Positive power distribution cable nut 9 - 80
Power steering pressure tube bolt 12 - 106
Power steering pump bracket bolts 24 18 -
Power steering pump bolts 25 18 -
Primary coolant pump bolts 10 - 89
Rocker arm assembly bolts (1) - - -
Secondary fuel filter assembly bolts 10 - 89
Secondary coolant pump mounting bolts 25 18 -
Starter harness ground bolt 25 18 -
Starter harness retainer bracket nut 12 - 106
Starter mounting bolts (1) - - -
Starter positive cable nut 12 - 106
Starter solenoid wire nut 5 - 44
Thermostat housing bolts 10 - 89
Throttle body bolts 10 - 89
Torque converter nuts 55 41 -
Transmission cooler tubes nut at engine 12 - 106
Transmission cooler tubes bracket nut 9 - 80
Transmission fluid indicator tube bolt at engine 11 - 97
Transmission fluid indicator tube nut at transmission 25 18 -
Transmission support insulator nuts 115 85 -
Transmission shift cable bracket bolt 48 35 -
Transmission-to-engine bolts 48 35 -
Turbocharger downpipe bracket bolt 25 18 -
Turbocharger downpipe clamp nut at turbocharger 15 - 133
Turbocharger downpipe clamp nut at pipe 55 41 -
Turbocharger downpipe flange bolt 40 30 -
Turbocharger heat shield bolts 10 - 89
Turbocharger inlet pipe clamp nut at turbine 15 - 133
Turbocharger inlet pipe nut at exhaust manifold 25 18 -
Turbocharger mounting bolts (1) - - -
Upper oil pan plug 102 75 -
Upper intake manifold bolts (1) - - -
Vacuum pump bolts 10 - 89
Valve cover bolts (1) - - -
Valve cover stud bolts (1) - - -
3/4 x 14 M cylinder block plug (HP oil) (1) - - -
1/2 x 14 M cylinder block upper plug (HP oil) (1) - - -
1/2 x 14 M cylinder block lower plug (water jacket drains) 40 30 -
M 27 x 2 x 6 cylinder block plug 72 53 -
(1) Refer to the procedure in this article.
scientia non olet · About LEMON Manuals