Section 434 (Driveline System - General Information -- F250-F550 Super Duty)
WARNING: This page is about a different car, the 2006 Ford Pickup, 2006 Ford F550 Super Duty, 2006 Ford F450 Super Duty, and 2006 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
- Description And Operation
- Diagnosis And Testing
- Driveline System
- Notes
- Inspection and Verification
- Notes
- Noise Acceptability
- Universal Joint (U-Joint) Inspection
- Analysis of Leakage
- Axle Vent
- Flange Yoke Seal
- Wheel Hub Oil Seals
- Analysis of Vibration
- Tires
- Driveline Angle
- Drive Pinion Stem and Pinion Flange
- Coupling Shaft/Center Bearing Alignment
- Bearing Shimming
- Axle Noise
- Gear Howl and Whine
- Bearing Whine
- Chuckle
- Knock
- Clunk
- Bearing Rumble
- Total Backlash Check
- Symptom Chart
- Component Tests
- Runout Check - Half-Round Companion Flange (Ford Axles Only)
- Differential Check - Traction-Lok® Road Test (Ford)
- Differential Check - Tractech® Truetrac® (Dana)
- Differential Check - Trac-Lok® Road Test (Dana)
- Tooth Contact Pattern Check - Gearset
- Contact Pattern Location
- Driveline System
- General Procedures