LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2009 >> Flex Limited, FWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1544 (Windows & Glass - Glass, Frames & Mechanisms) >> General Procedures >> Glass Reseal - Rear

Glass Reseal - Rear

WARNING: This page is about a different car, the 2009 Mercury Grand Marquis and 2009 Ford Crown Victoria. However, it is still accessible from the selected car via links, so may be relevant.
Material

Item Specification
DOW AUTOMOTIVE 2-HOUR CURE  
Dow Urethane Adhesive Betaseal® Express -
SIKA 2-HOUR CURE  
Sika Urethane Adhesive Sika Tack ASAP -
Ultra-Clear Spray Glass Cleaner
ZC-23
ESR-M14P5-A
  1. Remove the package tray trim panel. For additional information, refer to INTERIOR TRIM & ORNAMENTATION article.
  2. Disconnect the rear window glass electrical connectors.
  3. Clean the interior and exterior of the windshield glass surface with glass cleaner.
  4. Cut the urethane adhesive applicator tip to specification.
  5. Fig 1: Cutting Urethane Adhesive Applicator Tip To Specification
    GF0013185Courtesy of FORD MOTOR CO.
    NOTE: Use either a high ratio, electric or battery-operated caulk gun that applies the urethane with less effort and continuous bead.
    NOTE: Make sure that all gaps in the urethane adhesive are smoothed into one continuous bead.
  6. Apply the urethane adhesive over the top of the existing urethane adhesive.
    • Apply the urethane adhesive to the top and sides of the rear glass from the interior of the vehicle.
    • Apply the urethane adhesive to the bottom of the rear glass from the exterior of the vehicle.
  7. NOTE: The urethane adhesive must cure for a minimum of one hour before testing for air or water leaks.
  8. After the urethane cures, check the rear glass seal for air or water leaks through the urethane adhesive bead and add urethane adhesive as necessary.
  9. Connect the rear window glass electrical connectors.
  10. Install the package tray trim panel. For additional information, refer to INTERIOR TRIM & ORNAMENTATION article.