LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2007 >> Edge SE, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 791 (Engine - 6.0L Diesel -- F250-F550 Super Duty 6.0L (99P F450/550)) >> In-Vehicle Servicing >> Rocker Arm >> Installation

Rocker Arm: Installation

WARNING: This page is about a different car, the 2007 Ford Pickup, 2007 Ford F550 Super Duty, 2007 Ford F450 Super Duty, and 2007 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Identifying Valve Bridges
G03887388Courtesy of FORD MOTOR CO.
    NOTE: Apply clean engine oil on the valve stems prior to installing the valve bridges.
  1. Install the new valve bridges.
  2. Fig 2: Special Tool & Bolt
    GF0005737Courtesy of FORD MOTOR CO.
  3. Install the special tool plate and bolt. Tighten the bolt until the plate contacts the top of the tool base.
  4. Fig 3: Identifying Push Rods
    G03887392Courtesy of FORD MOTOR CO.
    CAUTION: To prevent engine damage, keep the push rods in the order in which they were removed. Install all push rods back in their original positions.
  5. Apply clean engine oil to each end of the push rods and insert them into their respective positions.
  6. Fig 4: Placing Dab Of Multi-Purpose Grease In The Fulcrum Socket
    GF0005738Courtesy of FORD MOTOR CO.
  7. Place a dab of multi-purpose grease in the fulcrum socket to hold the ball in place while installing the rocker arms.
  8. Fig 5: Locating Rocker Arm Retaining Clip
    G03887385Courtesy of FORD MOTOR CO.
    NOTE: Apply clean engine oil to the top center of the valve bridges prior to installing the rocker arms.
    NOTE: Always replace the rocker arm retaining clip with the same color clip.
  9. Insert the rocker arm under the fulcrum and ball, rotate the rocker arm into place and position onto the push rod. Install a new rocker arm retaining clip.
    • Repeat the step for the other rocker arm.
  10. Fig 6: Compressing Valve Spring
    GF0005735Courtesy of FORD MOTOR CO.
  11. Remove the special tool bolt and plate.
    • Make sure the rocker arms remain in place and the fulcrum ball has not fallen out.
  12. Fig 7: Installing Rubber Hose In The Oil Drain Holes
    GF0005734Courtesy of FORD MOTOR CO.
  13. Remove the rubber hose from the oil drain holes.
  14. Fig 8: Installing Assembly In Between The Bridges
    GF0005733Courtesy of FORD MOTOR CO.
  15. Remove the injector hold down and special tool base.
  16. Install the fuel injectors. For additional information, refer to FUEL CHARGING AND CONTROLS - 6.0L DIESEL article.