LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2006 >> Escape Hybrid, FWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 17 (Automatic Transmission - Cd4E) >> Diagnosis And Testing >> Diagnosis By Symptom >> Diagnostic Routines >> Other Concerns: External Leaks

Other Concerns: External Leaks

WARNING: This page is about a different variant/trim than selected.
OTHER CONCERNS: EXTERNAL LEAKS

Possible Component Reference/Action
252 - ELECTRICAL ROUTINE 
  • No Electrical Concerns
 -
352 - HYDRAULIC/MECHANICAL ROUTINE 
Fluid  -
  • Incorrect level
  • Fill to correct level.
Seals/Gaskets  -
  • Differential seals, speedometer gear, retainer seal, pump assembly, main control cover, servo cover, split flange gasket, converter impeller hub, manual lever shaft seal, fluid level indicator tube
  • Locate source of leak. Repair as required. If differential seal or converter impeller hub is leaking, inspect drain back holes in case/converter housing, inspect surface of linkshaft or front wheel driveshaft and joint for a rough surface. Rough surface may cause seal leakage. Repair as necessary.
Other  -
  • Fluid tube fitting, line pressure tap, pressure port plugs, drain plug, cooler tubes, case porosity, cracked case, cooler bypass valve
  • Locate source of leak. Repair as necessary.
  • Vent blocked or damaged
  • Check vent for damage or blockage. Repair as necessary.
  • Bolts at split flange or main control cover leaking
  • Inspect for leaks. Repair as necessary.
Sensors/Connectors  -
  • Transmission connectors, transmission range (TR) sensor. TSS sensor or seal
  • Locate source of leak. Repair as necessary.
scientia non olet · About LEMON Manuals