LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2005 >> Focus ZX5 S, Automatic >> Repair and Diagnosis (Single Page) >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Sunroof >> Diagnosis And Testing >> Roof Opening Panel >> Pinpoint Tests >> Pinpoint Test C: The Roof Opening Panel Leaks

Pinpoint Test C: The Roof Opening Panel Leaks

  1. C1 CHECK THE ROOF OPENING PANEL OPERATION 
    • Cycle the roof opening panel glass from the full-open position to the full-closed position.
    • Check the roof opening panel glass adjustment. REFER to ROOF OPENING PANEL ALIGNMENT .
    • Does the roof opening panel glass operate smoothly, close tightly and meet general adjustment specifications? 
  2. C2 CHECK THE ROOF OPENING PANEL WEATHERSTRIP 
    • Actuate the roof opening panel glass to the full-open position.
      • NOTE: The weatherstrip has a bonded butt joint located on the passenger side or rear edge. This is not a defect. Inspect the roof opening panel weatherstrip for cuts, tears, gouges and creases.
    • Is the roof opening panel weatherstrip damaged? 
  3. C3 CHECK THE ROOF OPENING PANEL REAR TROUGH AND TROUGH GUIDES 
      NOTE: The rear trough should travel back and forth smoothly with the roof opening panel glass.
    • Check the rear trough and trough guides for proper attachment and function.
    • Does the rear trough operate correctly? 
      • Yes  : GO to  C4.
      • No  : INSTALL a new roof opening panel assembly. REFER to ROOF OPENING PANEL .
  4. C4 CHECK THE ROOF OPENING PANEL DRAIN TUBES 
      NOTE: Drain hoses can be viewed with a flashlight by removing the headliner lace around the inside opening and gently pulling down on the headliner.
      NOTE: On some vehicles the trim lace has been replaced by Velcro® style attachments. Gain access to the roof opening panel frame drain tubes.
    • Are the drain tubes correctly positioned and properly attached. 
      • Yes  : GO to  C5.
      • No  : ADJUST or ATTACH the drain tube(s). GO to  C5.
  5. C5 CHECK THE ROOF OPENING PANEL DRAIN TUBES FLOW 
    NOTE: Drain hoses must flow downhill and can not be pinched or restricted by the headliner or any other trim components.
    • Open the roof opening panel.
    • Slowly  pour water into the trough area and make sure that the same amount of water exits the vehicle at the bottom of the A and C pillars.
    • Does the water properly drain through each of the drain tubes? 
      • Yes  : TAPE off the roof opening panel and INSPECT other areas of the vehicle that may cause water leaks to enter the roof area.
      • No  : CLEAR obstruction(s) with compressed air. REPEAT test. If obstruction is not clear, LOWER the headliner and INSPECT drain tube(s) for correct routing, pinches or restrictions. REPAIR as necessary.
scientia non olet · About LEMON Manuals