Inspection and Verification
WARNING: This page is about a different car, the 2010 Ford Pickup, 2010 Ford F550 Super Duty, 2010 Ford F450 Super Duty, and 2010 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
This service information provides mechanical diagnosis of the turbocharger assembly. If there is a Malfunction Indicator Lamp (MIL) illuminated, or DTCs are present, these should be diagnosed prior to performing turbocharger mechanical diagnosis. Refer to the
INTRODUCTION - GASOLINE MODELS
.
- Verify the customer concern.
- Inspect the entire turbocharger system for obvious signs of damage or other mechanical concerns, using the following chart.VISUAL INSPECTION CHART
Mechanical - Damaged intake hoses
- Loose hose clamps
- Damaged turbocharger
- Restricted intake or exhaust
- Damaged Charge Air Cooler (CAC)
- Damaged/plugged or disconnected Manifold Absolute Pressure (MAP) sensor
- Exhaust leaks
- Air leaks
- Turbocharger actuator linkage
- Inspect oil (dirty, incorrect level or diluted)
- Oil seal leaks
- If the concern(s) remains after the inspection, GO to SYMPTOM CHART .
- If a driveability condition still exists, refer to the INTRODUCTION - GASOLINE MODELS .