Torque Specifications
WARNING: This page is about a different car, the 2010 Ford Pickup, 2010 Ford F550 Super Duty, 2010 Ford F450 Super Duty, and 2010 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in | ||||||
|---|---|---|---|---|---|---|---|---|---|
| A/C compressor bolts | 25 | 18 | - | ||||||
| A/C drive belt tensioner bolt | 47 | 35 | - | ||||||
| A/C hose nut | 15 | - | 133 | ||||||
| Accessory drive belt idler pulley bolt | 47 | 35 | - | ||||||
| Accessory drive belt tensioner bolt | 47 | 35 | - | ||||||
| Air Cleaner (ACL) outlet pipe clamps | 5 | - | 44 | ||||||
| Automatic transmission fluid indicator tube nut | 8 | - | 71 | ||||||
| Battery cable bracket nut | 25 | 18 | - | ||||||
| Battery cable nut | 10 | - | 89 | ||||||
| Battery ground cable-to-engine block bolt | 47 | 35 | - | ||||||
| Block heater | 41 | 30 | - | ||||||
| Body bolts | 90 | 66 | - | ||||||
| Body ground strap bolt | 25 | 18 | - | ||||||
| Camshaft Position (CMP) sensor | 13 | - | 115 | ||||||
| Camshaft thrust plate-mounting bolts | 31 | 23 | - | ||||||
| Charge Air Cooler (CAC) duct clamps (engine and CAC side) | 12 | - | 106 | ||||||
| CAC duct clamps (metal duct side) | 8 | - | 71 | ||||||
| Connecting rod bearing cap bolts(1) | - | - | - | ||||||
| Coolant inlet port bolt | 13 | - | 115 | ||||||
| Coolant pump bolts | 31 | 23 | - | ||||||
| Coolant pump pulley bolts | 31 | 23 | - | ||||||
| Cooling fan stator nuts and bolts | 25 | 18 | - | ||||||
| Cooling fan stator stand offs | 47 | 35 | - | ||||||
| Crankcase vent oil separator bolts | 13 | - | 115 | ||||||
| Crankcase vent oil separator tube clip bolts | 25 | 18 | - | ||||||
| Crankcase vent oil separator tube retaining nut | 13 | - | 115 | ||||||
| Crankshaft Position (CKP) sensor | 13 | - | 115 | ||||||
| Crankshaft vibration damper bolts(1) | - | - | - | ||||||
| Cylinder block coolant drain plug(2) | 20 | - | 177 | ||||||
| Cylinder head bolts(1) | - | - | - | ||||||
| Degas bottle tray bolts | 19 | - | 168 | ||||||
| Engine cooling fan | 150 | 111 | - | ||||||
| Engine front cover bolts | 31 | 23 | - | ||||||
| Engine mount center bolt | 350 | 258 | - | ||||||
| Engine mount nuts - LH | 200 | 148 | - | ||||||
| Engine mount nuts - RH | 115 | 85 | - | ||||||
| Engine mount-to-engine bracket bolts(1) | - | - | - | ||||||
| Engine rear cover bolts (M8) | 31 | 23 | - | ||||||
| Engine rear cover bolts (M10) | 62 | 46 | - | ||||||
| Engine wire harness bolt | 8 | - | 71 | ||||||
| EGR coolant hose constant tension worm gear clamps | 4 | - | 35 | ||||||
| EGR cooler clamp nuts(1) | - | - | - | ||||||
| EGR cooler coolant tube bolts | 13 | - | 115 | ||||||
| EGR cooler hose clamp | 4 | - | 35 | ||||||
| EGR cooler outlet studs | 17 | - | 150 | ||||||
| EGR-Oxidation Catalytic Converter (OC) bracket bolt-to-cylinder block | 62 | 46 | - | ||||||
| EGR- OC bracket bolts | 31 | 23 | - | ||||||
| EGR- OC bracket nut and bolt | 31 | 23 | - | ||||||
| EGR- OC tube-to-horizontal EGR cooler bolts | 31 | 23 | - | ||||||
| EGR- OC tube-to-RH turbocharger inlet pipe bolts | 31 | 23 | - | ||||||
| Exhaust Gas Recirculation Temperature (EGRT) sensor - inlet | 44 | 32 | - | ||||||
| Exhaust downpipe bolts | 40 | 30 | - | ||||||
| Exhaust manifold bolts and stud bolts(1) | - | - | - | ||||||
| Exhaust manifold flange studs | 18 | - | 159 | ||||||
| Exhaust manifold heat shield mounting nuts and bolts | 19 | - | 168 | ||||||
| Exhaust manifold heat shield spacers | 19 | - | 168 | ||||||
| Exhaust Pressure (EP) sensor connector-to-EGR- OC tube fitting | 27 | 20 | - | ||||||
| EP sensor mounting nut | 9 | - | 80 | ||||||
| EP sensor tube nut | 20 | - | 177 | ||||||
| Flywheel/flexplate mounting bolts(1) | - | - | - | ||||||
| Front bumper mounting bolts | 47 | 35 | - | ||||||
| Front End Accessory Drive (FEAD) nuts and bolts | 47 | 35 | - | ||||||
| FEAD studs (with pre-applied sealant) | 9 | - | 80 | ||||||
| Front impact severity sensor bolt | 12 | - | 106 | ||||||
| Fuel cooler bolts(1) | - | - | - | ||||||
| Fuel cooler nuts(1) | - | - | - | ||||||
| Fuel cooler stud bolts(1) | - | - | - | ||||||
| Fuel cooling pump bolts | 3 | - | 27 | ||||||
| Fuel filter cap | 27 | 20 | - | ||||||
| Fuel filter module bolts | 13 | - | 115 | ||||||
| Fuel injection pump supply tube retainer nuts | 11 | - | 97 | ||||||
| Fuel injector hold-down bolt(1) | - | - | - | ||||||
| Fuel injector return tube nut-to-check valve | 28 | 21 | - | ||||||
| Fuel injector return tube retainer bolts | 13 | - | 115 | ||||||
| Fuel injector return tube retainer nut | 11 | - | 97 | ||||||
| Fuel pump heat shield fuel line bracket | 7 | - | 62 | ||||||
| Fuel pump heat shield nuts and bolts | 13 | - | 115 | ||||||
| Fuel rail supply tube(1) | - | - | - | ||||||
| Fuel rail supply tube bracket bolts | 13 | - | 115 | ||||||
| Fuel return plug (back of head) | 28 | 21 | - | ||||||
| Fuel supply and return tube clamp bolt | 31 | 23 | - | ||||||
| Generator B+ wire nut | 8 | - | 71 | ||||||
| Glow plug | 14 | - | 124 | ||||||
| Glow plug module mounting bracket bolts | 13 | - | 115 | ||||||
| Glow plug module retaining nuts | 13 | - | 115 | ||||||
| Ground cable bolt | 47 | 35 | - | ||||||
| Ground strap nut | 13 | - | 115 | ||||||
| Heater hose tube nut and bolts (supply and return) | 13 | - | 115 | ||||||
| High-pressure fuel injection pump cover bolts | 13 | - | 115 | ||||||
| High-pressure fuel pump gear bolt | 78 | 58 | - | ||||||
| High-pressure fuel pump mounting bolts | 62 | 46 | - | ||||||
| High-pressure fuel pump tube nut | 38 | 28 | - | ||||||
| High-pressure fuel tube fittings(1) | - | - | - | ||||||
| High-Pressure Pump Test Adapter (303-765) | 12 | - | 106 | ||||||
| High-pressure rail mounting bolts(1) | - | - | - | ||||||
| Hood bolts | 13 | - | 115 | ||||||
| Horizontal EGR cooler outlet nuts | 31 | 23 | - | ||||||
| Intake manifold bolts(1) | - | - | - | ||||||
| Intake throttle adapter bolts | 10 | - | 89 | ||||||
| LH valve cover bracket assembly nuts | 31 | 23 | - | ||||||
| LH valve cover bracket nuts | 9 | - | 80 | ||||||
| Lower crankcase main bearing bolts(1) | - | - | - | ||||||
| M12 banjo bolts with copper sealing washer | 38 | 28 | - | ||||||
| M12 banjo bolts with Viton® sealing washers | 25 | 18 | - | ||||||
| M14 banjo bolts with copper sealing washer | 47 | 35 | - | ||||||
| M14 banjo bolts with Viton® sealing washers | 28 | 21 | - | ||||||
| Master cylinder nuts | 30 | 22 | - | ||||||
| Oil cooler bolts | 31 | 23 | - | ||||||
| Oil cooler cover screws - new cover | 10 | - | 89 | ||||||
| Oil cooler cover screws - used cover | 7 | - | 62 | ||||||
| Oil filter cap | 25 | 18 | - | ||||||
| Oil filter housing bolts | 22 | 16 | - | ||||||
| Oil filter return tube screw - new | 7 | - | 62 | ||||||
| Oil filter return tube screw - used | 5 | - | 44 | ||||||
| Oil level indicator tube bolt | 13 | - | 115 | ||||||
| Oil level indicator tube nut | 31 | 23 | - | ||||||
| Oil pan bolt - lower | 13 | - | 115 | ||||||
| Oil pan bolts - upper | 13 | - | 115 | ||||||
| Oil pan drain plug | 44 | 32 | - | ||||||
| Oil pickup tube flange bolts | 13 | - | 115 | ||||||
| Oil pressure regulator plug | 35 | 26 | - | ||||||
| Oil pump housing bolts - long bolts | 31 | 23 | - | ||||||
| Oil pump housing bolts - short bolts | 22 | 16 | - | ||||||
| Piston cooling tube bolt(3) | 13 | - | 115 | ||||||
| Power steering pump bolts | 25 | 18 | - | ||||||
| Power steering tube nut | 25 | 18 | - | ||||||
| RH engine mount studs | 80 | 59 | - | ||||||
| Rocker arm assembly bolts(1) | - | - | - | ||||||
| Running board bolts | 13 | - | 115 | ||||||
| Starter control wire nut | 6 | - | 53 | ||||||
| Starter mounting bolts | 25 | 18 | - | ||||||
| Starter positive cable nut | 12 | - | 106 | ||||||
| Steering damper nut | 35 | 26 | - | ||||||
| Steering shaft bolt | 48 | 35 | - | ||||||
| Thermostat housing retaining bolts | 13 | - | 115 | ||||||
| Torque converter nuts | 35 | 26 | - | ||||||
| Transmission cooler tubes nut | 9 | - | 80 | ||||||
| Transmission fluid indicator tube nut | 8 | - | 71 | ||||||
| Transmission mount nuts | 115 | 85 | - | ||||||
| Transmission-to-engine bolts | 47 | 35 | - | ||||||
| Turbocharger actuator cooler bolts(1) | - | - | - | ||||||
| Turbocharger bolts (M14, socket head, class 12.9) | 201 | 148 | - | ||||||
| Turbocharger crossover tube bolts | 31 | 23 | - | ||||||
| Turbocharger downpipe clamp nut | 15 | - | 133 | ||||||
| Turbocharger heat shield bolts | 11 | - | 97 | ||||||
| Turbocharger inlet pipe-to-exhaust manifold nuts | 31 | 23 | - | ||||||
| Turbocharger inlet pipe-to-turbocharger bolts | 25 | 18 | - | ||||||
| Turbocharger Lifting Bracket bolts (303-1266) | 20 | - | 177 | ||||||
| Turbocharger oil supply banjo bolts with copper sealing washer | 38 | 28 | - | ||||||
| Turbocharger oil supply banjo bolts with Viton® sealing washers | 25 | 18 | - | ||||||
| Turbocharger oil supply standoff fittings | 47 | 35 | - | ||||||
| Turbocharger oil supply tube bolt | 13 | - | 115 | ||||||
| Turbocharger pedestal bolts | 62 | 46 | - | ||||||
| Valve cover base bolts | 13 | - | 115 | ||||||
| Valve cover bolts | 9 | - | 80 | ||||||
| Valve tappet guide bolts | 13 | - | 115 | ||||||
| Vertical EGR cooler bracket bolt (M10) | 62 | 46 | - | ||||||
| Vertical EGR cooler bracket bolts (M8) | 31 | 23 | - | ||||||
| Vertical EGR cooler-to-EGR valve housing nut and bolt | 31 | 23 | - | ||||||
| Vertical EGR cooler-to-EGR valve housing stud | 17 | - | 150 | ||||||
|
|||||||||
TORQUE SPECIFICATIONS
| Thread Diameter | Thread Pitch (mm/thread) | Torque(1) | ||
|---|---|---|---|---|
| 6 mm | 1 | 13 Nm (115 lb-in) |
||
| 8 mm | 1.25 | 31 Nm (23 lb-ft) | ||
| 10 mm | 1.5 | 62 Nm (46 lb-ft) | ||
| 12 mm | 1.75 | 107 Nm (79 lb-ft) |
||
| 14 mm | 2 | 172 Nm (127 lb-ft) |
||
| 15 mm | 2 | 216 Nm (159 lb-ft) |
||
| 16 mm | 2 | 266 Nm (196 lb-ft) |
||
| 18 mm | 2.5 | 368 Nm (271 lb-ft) |
||
| 20 mm | 2.5 | 520 Nm (384 lb-ft) |
||
|
||||
TORQUE SPECIFICATIONS
| Thread Diameter | Thread Pitch (mm/thread) | Torque(1) | ||
|---|---|---|---|---|
| 6 mm | 1 | 15 Nm (133 lb-in) |
||
| 8 mm | 1.25 | 36 Nm (27 lb-ft) | ||
| 10 mm | 1.5 | 72 Nm (53 lb-ft) | ||
| 12 mm | 1.75 | 126 Nm (93 lb-ft) |
||
| 14 mm | 2 | 201 Nm (148 lb-ft) |
||
| 15 mm | 2 | 252 Nm (186 lb-ft) |
||
| 16 mm | 2 | 311 Nm (229 lb-ft) |
||
| 18 mm | 2.5 | 430 Nm (317 lb-ft) |
||
| 20 mm | 2.5 | 608 Nm (449 lb-ft) |
||
|
||||