240,000 Km (150,000 Miles)
WARNING: This page is about a different car, the 2007 Ford Pickup, 2007 Ford F550 Super Duty, 2007 Ford F450 Super Duty, and 2007 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
- Change engine oil and install a new oil filter.
- Rotate tires and inspect for wear.
- Inspect brake pads, shoes, rotors, drums, brake lines, hoses and parking brake system.
- Inspect wheel ends for end play and noise.
- Inspect engine cooling system and hoses.
- Change Motorcraft Premium Gold coolant (see Exceptions To Normal Schedule and Mileage Base).
- Inspect exhaust system and heat shields.
- Inspect steering linkage, suspension and ball joints.
- Inspect halfshafts, driveshaft and U-joints (if equipped).
- Install a new fuel filter (not required for Fusion and Milan).
- Install a new engine air filter (not required on Focus).
- Check air filter restriction gauge, install a new air filter as necessary (Focus only).
- Install a new cabin air filter (if equipped).
- Change automatic transmission/transaxle fluid (except CVT transmission).
- Change automatic transaxle filter (except CVT, Five Hundred and Montego equipped with a 6-speed automatic transaxle).
- Change rear axle lubricant on all RWD vehicles.
- Change rear axle fluid (Class A Motorhome).
- Install a new accessory drive belt(s) (if a new belt has not been installed within the last 100,000 miles).
- Install new climate controlled seat cushion filters (if equipped) (Navigator, Freestar, Monterey and Expedition).
- Install a new climate controlled seat back filter (MKZ only).
- Inspect PVC for flow (3V engines).
- Lubricate steering linkage, suspension and ball joints (if equipped with zerk fittings).
- Install new non-sealed RWD front wheel bearings and seals (if new bearings and seals have not been installed in the last 100,000 miles).
- Lubricate the 4WD front axle shaft U-joints (if equipped) (F-250/350/450/550).
- Change front axle lubricant (4WD only).
- Change transfer case fluid (4WD only).
- Change automatic transmission/transaxle fluid on all vehicles equipped with a 4F50N, 5R44E, 5R55E, 5R555, TorqShift (with externally mounted remote filter) and CD4E transmission/transaxle. Install a new remote filter if equipped with a TorqShift transmission. Inspect automatic transmission fluid level using the fluid level indicator on all other vehicles (if equipped with an underhood fluid level indicator). Change the in-line service-installed transmission fluid filter (if equipped).
- Carry-out multi-point inspection (recommended).