LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Taurus LX, 3.0 2, AX4N >> Repair and Diagnosis >> External Pages >> Different car >> Section 1461 (Engine Mechanical - 2.5L (Hybrid)) >> Specifications >> Torque Specification

Torque Specification

WARNING: This page is about a different car, the 2010 Mercury Mariner and 2010 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATION

Description Nm lb-ft lb-in
ABS sensor bolt 15 - 133
A/C compressor bracket bolts 48 35 -
A/C compressor mounting bolts 25 18 -
A/C manifold tube-to-A/C compressor nut 15 - 133
A/C tube bracket nut 10 - 89
Accessory drive belt tensioner 25 18 -
Auxiliary coolant pump bolts 10 - 89
Balance shaft bolts (1) - - -
Block heater (if equipped) 40 30 -
Block-off plate bolts 25 18 -
Camshaft bearing caps (1) - - -
Camshaft sprocket bolt 72 53 -
Catalytic converter-to-cylinder head nuts (1) - - -
Coil-on-plug retaining stud bolts 8 - 71
Connecting rod cap bolts (1) - - -
Coolant outlet bolts 10 - 89
Coolant pump bolts 10 - 89
Coolant pump pulley bolts 20 - 177
Crankcase vent oil separator bolts 10 - 89
Crankshaft Position (CKP) sensor 7 - 62
Crankshaft pulley bolt (1) - - -
Cylinder head bolts (1) - - -
Cylinder Head Temperature (CHT) sensor 12 - 106
DC-to-DC converter nuts 12 - 106
EGR tube 55 41 -
EGR valve assembly bolts 20 - 177
Engine front cover bolts (1) - - -
Engine Oil Pressure (EOP) switch 15 - 133
Engine mount bolts 48 35 -
Engine mount bracket-to-engine nuts 115 85 -
Engine mount bracket-to-mount bolt 115 85 -
Engine plug bolt 20 - 177
Engine support crossmember bolts 90 66 -
Engine support crossmember nut 175 129 -
Engine timing plug bolt 20 - 177
Engine wiring harness connector bracket 15 - 133
Exhaust bracket bolts 25 18 -
Exhaust manifold studs 17 - 150
Flywheel bolt (1) - - -
Fuel rail bolts 23 17 -
Intake manifold bolts 18 - 159
Intermediate shaft bearing retainer nuts 27 20 -
Knock Sensor (KS) 20 - 177
Lateral support crossmember bolts 115 85 -
Lower front cover timing hole plug 12 - 106
Lower insulator through bolt 115 85 -
Main bearing beam bolts (1) - - -
Motor Electronics Cooling System (MECS) pump bolts 20 - 177
Oil drain plug 28 21 -
Oil filter adapter bolts 25 18 -
Oil filter (2) - - -
Oil pan bolts (1) - - -
Oil pan-to-bellhousing bolts 48 35 -
Oil pump drive chain tensioner shoulder bolts 10 - 89
Oil pump screen and pickup tube 10 - 89
Oil pump sprocket bolt 25 18 -
Oil pump-to-engine block bolts (1) - - -
Oil squirters 4 - 35
Power Transfer Unit (PTU) bolts 45 33 -
PTU heat shield bolts 11 - 97
PTU-to-engine support bracket bolts 40 30 -
Radio capacitor nut 10 - 89
Rear crankshaft oil seal retainer (1) - - -
Rear insulator through bolt 115 85 -
Rear roll restrictor bracket bolts 90 66 -
Rear roll restrictor-to-crossmember through bolt 90 66 -
Spark plug 12 - 106
Splash shield bolts 9 - 80
Stabilizer bar link nuts 63 46 -
Steering column coupling-to-steering gear pinch bolt 63 46 -
Subframe bolts 175 129 -
Subframe nuts 150 111 -
Thermostat housing bolts 10 - 89
Tie-rod end nuts 55 41 -
Timing chain guide bolts 10 - 89
Timing chain tensioner bolts 10 - 89
Transaxle control cable bracket nuts 22 16 -
Transaxle control snow shield bolts 22 16 -
Transaxle damper bolts 29 21 -
Transaxle harness electrical connector bolt 10 - 89
Transaxle-to-engine bolts 48 35 -
Upper transaxle insulator bracket 25 18 -
Upper transaxle insulator nuts 90 66 -
Upper transaxle insulator through bolt 103 76 -
Upper front cover timing hole plug 10 - 89
Vacuum pump assembly bolts 25 18 -
Vacuum pump assembly nut 25 18 -
Valve cover bolts (1) - - -
Variable Camshaft Timing (VCT) plug 17 - 150
VCT solenoid bolt 10 - 89
Wiring harness ground cable nut 20 - 177
(1) Refer to the procedure in this article.
(2) Tighten the spin-on oil filter three-fourths of a turn after the oil filter gasket makes contact with the oil filter adapter.
scientia non olet · About LEMON Manuals