LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Taurus LX, 3.0 2, AX4N >> Repair and Diagnosis >> External Pages >> Different car >> Section 1459 (Engine Mechanical - 2.5L (Except Hybrid)) >> Specifications >> Torque Specification

Torque Specification

WARNING: This page is about a different car, the 2010 Mercury Mariner and 2010 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATION

Description Nm lb-ft lb-in
A/C compressor mounting bolts 25 18 -
Accessory drive belt idler pulley and bracket bolts 25 18 -
Accessory drive belt idler pulley bolt 25 18 -
Accessory drive belt tensioner bolts 25 18 -
Air Cleaner (ACL) outlet pipe-to-Throttle Body (TB) clamp 4 - 35
Balance shaft bolts (1) - - -
Bellhousing-to-engine bolts 48 35 -
Blocker heater 40 30 -
Camshaft bearing cap bolts (1) - - -
Camshaft sprocket bolts 72 53 -
Clutch hydraulic line 25 18 -
Clutch hydraulic line bracket-to-transaxle bolt 3 - 27
Coil-on-plug stud bolts 8 - 71
Connecting rod cap bolts (1) - - -
Coolant outlet bolts 10 - 89
Coolant pump bolts 10 - 89
Coolant pump pulley bolts 20 - 177
Crankcase vent oil separator bolts 10 - 89
Crankshaft Position (CKP) sensor bolts (1) - - -
Crankshaft pulley bolt a - - -
Crankshaft rear oil seal retainer bolts (1) - - -
Cylinder head bolts (1) - - -
Cylinder Head Temperature (CHT) sensor 12 - 106
Dampener bolts 40 30 -
Driveshaft bolts 37 27 -
EGR tube 55 41 -
EGR valve bolts 20 - 177
Engine front cover bolts (1) - - -
Engine front cover-to-oil pan bolts (1) - - -
Engine mount bolts 48 35 -
Engine mount bracket bolt 115 85 -
Engine mount bracket nuts 115 85 -
Engine Oil Pressure (EOP) switch 15 - 133
Engine plug bolt 20 - 177
Engine support crossmember bolts 90 66 -
Engine support crossmember nut 175 129 -
Engine-to-bellhousing bolts 48 35 -
Exhaust manifold heat shield bolts 10 - 89
Exhaust manifold nuts (1) - - -
Exhaust manifold stud bolts 17 - 150
Flexplate bolts (1) - - -
Flywheel bolts (1) - - -
Front roll restrictor bolt 115 85 -
Fuel rail stud bolts 23 17 -
Generator electrical connection nut 6 - 53
Generator mounting bolt and nuts 47 35 -
Ground eyelet bolt 10 - 89
Ground strap bolt 10 - 89
Intake manifold bolts 18 - 159
Intermediate shaft bearing retainer nuts 27 20 -
Knock Sensor (KS) bolt 20 - 177
Lateral support crossmember bolts 115 85 -
LH splash shield bolts 9 - 80
LH transaxle mount bolt 103 76 -
Lower front cover timing hole plug 12 - 106
Main bearing beam bolts (1) - - -
Oil filter adapter bolts 25 18 -
Oil filter (spin-on filter type) (2) - - -
Oil pan-to-bellhousing bolts (1) - - -
Oil pan bolts (1) - - -
Oil pan drain plug 28 21 -
Oil pump drive chain tensioner bolt 10 - 89
Oil pump drive chain tensioner shoulder bolt 10 - 89
Oil pump bolts (1) - - -
Oil pump screen and pickup tube bolts 10 - 89
Oil pump sprocket bolt 25 18 -
Oil squirters 4 - 35
Power Distribution Box (PDB) cable nut 12 - 106
Power Transfer Unit (PTU) bolts 70 52 -
PTU bracket bolts 45 33 -
PTU bracket-to-engine bolts 40 30 -
PTU heat shield bolts 11 - 97
PTU lower LH bolt 45 33 -
Pressure plate bolts 29 21 -
Radio capacitor bolt 20 - 177
Radio capacitor nut 10 - 89
Rear transaxle mount bolt 115 85 -
RH splash shield bolts 9 - 80
Shift cable bracket bolts 22 16 -
Spark plug 12 - 106
Starter motor bolts 35 26 -
Starter motor solenoid battery nut 12 - 106
Starter motor solenoid nut 5 - 44
Starter motor ground wire nut 25 18 -
Thermostat housing bolts 10 - 89
Timing chain guide bolts 10 - 89
Timing chain tensioner bolts 10 - 89
Torque converter nuts 35 26 -
Transaxle-to-engine bolts 48 35 -
Transaxle-to-PTU bolt 48 35 -
Upper engine bracket-to-PTU bolts 45 33 -
Upper front cover timing hole plug 10 - 89
Valve cover bolts (1) - - -
Variable Camshaft Timing (VCT) oil control solenoid bolt 10 - 89
VCT  system oil filter plug 17 - 150
(1) Refer to the procedure for this specification.
(2) Lubricate the spin-on oil filter gasket with clean engine oil. Tighten the oil filter three-fourths turn after the oil filter gasket makes contact with the oil filter adapter.
scientia non olet · About LEMON Manuals