Brake Shoes &/Or Pads: Remove & Replace

WARNING: This page is about the Explorer 2D Utility, 4.0 E, 4WD, which is a different variant/trim than selected.

Includes: Clean, lube and/or replace Brake Hardware as necessary. Adjust Brakes (where applicable). Includes: Repack Wheel Bearings (where applicable). DOES NOT include refinishing.

Applies To	Note	Standard Hours	Skill Level
All,Both Axles		1.8	B
Front,Both Sides		1.0	B
Rear,Both Sides		1.0	B
Combination Procedure: AXLE SEAL: Replace: Semi-Floating Axle.
Rear,Both,w/Limited Slip		1.3	B
Rear,Both,w/o Limited Slip		1.2	B
Rear,One Side,w/Limited Slip		1.1	B
Rear,One Side,w/o Limited Slip		1.0	B
Combination Procedure: BRAKE HOSE: Replace: Includes: Bleed Brake System.
Each Additional		0.2	B
One		0.4	B
Combination Procedure: CALIPER: Overhaul:
One,Dual Piston	Includes: Bleed Brakes.	0.7	B
One,Single Piston	Includes: Bleed Brakes.	0.5	B
Combination Procedure: CALIPER: Replace:
One	Includes: Bleed Brakes.	0.3	B
Combination Procedure: DISC ROTOR: Burnish Brake Rotors While Driving Vehicle:
		0.5	B
Combination Procedure: DISC ROTOR: Remove and Install for Refinishing: NOTE: This operation does not apply to drive axles. If on vehicle refinishing is not possible use appropriate repair operation.
4WD, Front	Not Applicable.		B
Rear	Not Applicable.		B
Combination Procedure: DISC ROTOR: Replace:
4WD, Front,Each		0.1	B
Rear,Each		0.1	B
Combination Procedure: PARKING BRAKE SHOE & LINING: Replace:
Both Sides		0.6	B
Combination Procedure: WHEEL BEARING: Replace:
4WD, Front,One Side,Non Separable		0.8	B
Rear,Both,w/Limited Slip		1.9	B
Rear,Both,w/o Limited Slip		1.8	B
Rear,One Side,w/Limited Slip		1.4	B
Rear,One Side,w/o Limited Slip		1.3	B