Section 81 (Engine Removal, Overhaul & Installation -- ECONOLINE, Excursion & F250-F550 Super Duty - Diesel 7.3L (99F E Series & 99F F450/550)): Introduction
WARNING: This page does not describe the selected car, but rather 10 other vehicles, including the 2002 Ford RV Cutaway, 2002 Ford Pickup, 2002 Ford F550 Super Duty, 2002 Ford F450 Super Duty, and 2002 Ford Excursion. However, it is still accessible from the selected car via links, so may be relevant.
WARNING:
On vehicles with dual batteries, disconnect and reconnect battery cables in specified order. To disconnect batteries, disconnect negative battery cable from secondary battery, located on driver's side of engine compartment, then disconnect negative battery cable from primary battery, located on passenger's side of engine compartment. To connect batteries, connect negative battery cable to primary battery, located on passenger's side of engine compartment then connect negative battery cable to secondary battery, located on driver's side of engine compartment.
NOTE:
References to Econoline include Cutaway and RV Cutaway. References to Pickup include Cab & Chassis.
Removal, overhaul, and installation procedures are covered in this article. If component removal and installation is primarily an unbolt and bolt-on procedure, only a torque specification may be furnished.