SANDEN TRS-90 & Tr-105 Scroll
- Slowly discharge A/C system, using approved refrigerant recovery/recycling equipment. Measure amount of oil drained during A/C system discharge. Disconnect refrigerant hoses at compressor. Remove compressor bolts and A/C compressor.
- Drain and measure oil from suction and discharge ports of old compressor. Drain oil from replacement compressor and save. Add the same amount of refrigerant oil to replacement compressor as was drained from old compressor. When repairing an excessive leak in A/C system, add one ounce additional oil to compressor.
- Add proper amount of refrigerant oil to any components being replaced. DO NOT add more refrigerant oil than A/C system total. See SANDEN TRS-90 & TR-105 COMPONENT REFRIGERANT OIL CAPACITIES (2000) or SANDEN TRS-90 & TR-105 COMPONENT REFRIGERANT OIL CAPACITIES (2001) table. Install compressor. Evacuate, charge and leak test A/C system. Ensure A/C system operates properly.
SANDEN TRS-90 & TR-105 COMPONENT REFRIGERANT OIL CAPACITIES (2000)
| Component |
Ounces |
| Breeze, Cirrus, Sebring Convertible & Stratus |
| Compressor |
5.0 |
| Condenser |
1.0 |
| Evaporator |
2.0 |
| Receiver-Drier |
1.0 |
| Refrigerant Line |
1.5 |
| System Total |
5.1 |
| Ram Van/Wagon |
| Compressor |
|
| Condenser |
1.0 |
| Evaporator |
| Front |
2.0 |
| Rear (Combination Coil) |
2.0 |
| Receiver-Drier |
1.0 |
| System Total |
| With Rear Unit |
10.0 |
| Without Rear Unit |
8.0 |
SANDEN TRS-90 & TR-105 COMPONENT REFRIGERANT OIL CAPACITIES (2001)
| Component |
Ounces |
| Sebring Convertible, Sebring Sedan & Stratus Sedan |
| Compressor |
5.0 |
| Condenser |
1.0 |
| Evaporator |
2.0 |
| Receiver-Drier |
1.0 |
| Refrigerant Line |
1.5 |
| System Total |
5.1 |
| Ram Van/Wagon |
| Compressor |
|
| Condenser |
1.0 |
| Evaporator |
| Front |
2.0 |
| Rear (Combination Coil) |
2.0 |
| Receiver-Drier |
1.0 |
| System Total |
| With Rear Unit |
10.0 |
| Without Rear Unit |
8.0 |