Torque Specifications
WARNING: This page is about a different car, the 2005 Ford RV Cutaway, 2005 Ford Econoline, 2005 Ford E450 Super Duty, and 2005 Ford Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in | ||
|---|---|---|---|---|---|
| Balancer shaft bearing cap bolts and studs | 10 | - | 89 | ||
| Valve cover bolts | 10 | - | 89 | ||
| Camshaft bearing cap bolts | 10 | - | 89 | ||
| Camshaft sprocket bolts(1) | - | - | - | ||
| Cylinder head temperature (CHT) sensor | 26 | 19 | - | ||
| Camshaft position (CMP) sensor bolt | 10 | - | 89 | ||
| Crankshaft position (CKP) sensor bolt | 10 | - | 89 | ||
| Connecting rod bolts(1) | - | - | - | ||
| Crankshaft damper pulley bolt(1) | - | - | - | ||
| Crankshaft main bearing bolts (cross mounted)(1) | - | - | - | ||
| Crankshaft main bearing bolts (vertical)(1) | - | - | - | ||
| Cylinder heads bolts(1) | - | - | - | ||
| Exhaust manifold nuts | 25 | 18 | - | ||
| Exhaust manifold studs | 12 | 9 | - | ||
| Accessory drive belt idler pulley bolt | 25 | 18 | - | ||
| Flexplate bolts | 80 | 59 | - | ||
| Engine front cover bolts (1 - 5) | 25 | 18 | - | ||
| Engine front cover bolts (6 - 15) | 48 | 35 | - | ||
| Fuel injection supply manifold bracket bolts | 10 | - | 89 | ||
| Heater return tube studs | 40 | 30 | - | ||
| Ignition coil | 6 | - | 53 | ||
| Knock sensor (KS) bolt | 20 | 15 | - | ||
| Intake manifold-to-cylinder head bolts(1) | - | - | - | ||
| Oil bypass filter | 16 | 12 | - | ||
| Oil filter adapter bolt | 25 | 18 | - | ||
| Oil filter adapter nut | 47 | 35 | - | ||
| Wiring harness bracket nut | 25 | 18 | - | ||
| Oil filter adapter stud | 12 | 9 | - | ||
| Oil level indicator bolt | 10 | - | 89 | ||
| Oil pan bolts(1) | - | - | - | ||
| Oil pan drain plug | 23 | 17 | - | ||
| Oil pressure sender | 14 | 10 | - | ||
| Oil pump bolts | 10 | - | 89 | ||
| Oil pump screen cover and tube bolts | 10 | - | 89 | ||
| Oil pump screen and pickup tube spacer | 25 | 18 | - | ||
| Power steering pump bolts | 25 | 18 | - | ||
| Crankshaft rear seal retainer plate bolts | 10 | - | 89 | ||
| Spark plugs | 18 | 13 | - | ||
| Coolant outlet bolts | 25 | 18 | - | ||
| Throttle body spacer to intake manifold bolts(1) | - | - | - | ||
| Throttle body-to-throttle body spacer bolts(1) | - | - | - | ||
| Timing chain guide bolts | 10 | - | 89 | ||
| Timing chain hydraulic tensioner bolts | 25 | 18 | - | ||
| Coolant pump bolts | 25 | 18 | - | ||
| Coolant pump pulley bolts | 25 | 18 | - | ||
| Transmission cooler tube nut | 25 | 18 | - | ||
| Oil cooler threaded insert | 58 | 43 | - | ||
| Engine mount nuts | 90 | 66 | - | ||
| Engine mount bolts | 80 | 59 | - | ||
| Dual converter Y-pipe nuts | 40 | 30 | - | ||
| Torque converter nuts | 40 | 30 | - | ||
| Transmission-to-engine bolts | 47 | 35 | - | ||
| Fan shroud bolts | 6 | - | 53 | ||
| Oil level indicator-to-front cover nut | 25 | 18 | - | ||
| Engine cooling fan clutch | 133 | 98 | - | ||
| Transmission cooler tubes bracket nut | 12 | 9 | - | ||
| A/C compressor mounting bolts | 25 | 18 | - | ||
| Generator mounting bolts | 25 | 18 | - | ||
| Generator mounting bracket bolts | 10 | - | 89 | ||
| Accessory drive belt tensioner bolts | 25 | 18 | - | ||
| Flywheel inspection plate bolts | 34 | 25 | - | ||
| Radiator bracket mounting bolts | 20 | 15 | - | ||
| A/C condenser tube (small) | 18 | 13 | - | ||
| A/C condenser tube (large) | 39 | 29 | - | ||
| A/C suction tube nut | 47 | 35 | - | ||
| A/C condenser bracket bolts | 12 | 9 | - | ||
| Starter mounting bolts/stud bolt | 25 | 18 | - | ||
| Starter ground cable nut | 20 | 15 | - | ||
| Starter positive cable nut | 12 | 9 | - | ||
| Starter control wire nut | 6 | - | 53 | ||
| Oil fill tube bolt | 10 | - | 89 | ||
| Cylinder block drain plug | 24 | 18 | - | ||
| Radio frequency interference capacitor | 25 | 18 | - | ||
| Hood latch bolts | 12 | 9 | - | ||
| Power steering reservoir bolts | 20 | 15 | - | ||
| Upper and lower radiator support bracket bolts | 20 | 15 | - | ||
| Fuel charging wiring harness nuts/bolts | 10 | - | 89 | ||
| Clean air tube clamps | 4 | - | 35 | ||
| Air cleaner assembly bolts | 7 | - | 62 | ||
|
|||||