LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 746 (Engine Controls - Diagnostic Subroutines - 6.0L Diesel (99P E-Series & 99P F450/550)) >> Performance Diagnostic Procedures >> 15. Oil Aeration Test >> Recommended Procedure:

Recommended Procedure:

WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2004 Ford RV Cutaway, 2004 Ford Pickup, 2004 Ford F550 Super Duty, 2004 Ford F450 Super Duty, and 2004 Ford Excursion. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: The engine must be at operating temperature.
  1. Remove the EOT sensor. For additional information, refer to the FUEL CHARGING & CONTROLS .
  2. Install the High Pressure Pump Test Adapter 303-765 or equivalent and Gauge 0-1.1 MPa (0 -160 psi) Bar 014-00761 or equivalent.
  3. Increase the engine speed to 3,000 RPM and maintain for 1 minute.
  4. Return the engine speed to idle.
  5. Obtain an oil sample with the engine at idle.
scientia non olet · About LEMON Manuals