Section 734 (Noise, Vibration & Harshness)
WARNING: This page is about a different car, the 2004 Ford RV Cutaway, 2004 Ford Econoline, 2004 Ford E450 Super Duty, and 2004 Ford Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
- Description And Operation
- Diagnosis And Testing
- Noise, Vibration and Harshness (NVH)
- Special Tool(s)
- 1: Customer Interview
- 2: Pre-Drive Check
- 3: Preparing for the Road Test
- 4: Verify the Customer Concern
- 5: Road Test
- 6: Check TSBs/Repair History
- 7: Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Symptom Chart - Air Leak and Wind Noise
- Symptom Chart - Brake Noise/Vibration
- Symptom Chart - Driveline Noise/Vibration
- Symptom Chart - Engine Noise/Vibration
- Symptom Chart - Idle Noise/Vibration
- Symptom Chart - Squeak and Rattle
- Symptom Chart - Steering Noise/Vibration
- Symptom Chart - Suspension Noise/Vibration
- Symptom Chart - Tire Noise/Vibration
- Symptom Chart - Transmission (Manual) and Transfer Case Noise/Vibration
- Symptom Chart - Transmission (Automatic) Noise/Vibration
- Pinpoint Tests
- Notes
- Pinpoint Test A: Brake Vibration/Shudder
- Pinpoint Test B: Engine Ticking Noise
- Pinpoint Test C: Accessory Drive Bearing Hoot
- Pinpoint Test D: Power Steering Moan
- Pinpoint Test E: Engine Driven Cooling Fan Moan
- Pinpoint Test F: Drumming Noise
- Pinpoint Test G: Engine Ticking, Knocking Or Continuous Rattle
- Pinpoint Test H: Front Suspension Noise
- Pinpoint Test I: Rear Suspension Noise
- Pinpoint Test J: Wheel And Tire
- Pinpoint Test K: High Speed Shake Or Shimmy Diagnosis
- Pinpoint Test L: Clutch Vibration
- Pinpoint Test M: Transfer Case Vibration
- Component Tests
- Checking Tooth Contact Pattern and Condition of the Ring and Pinion
- Tire Wear Patterns And Frequency Calculations
- Noise, Vibration and Harshness (NVH)
- General Procedures