Torque Specifications
WARNING: This page is about a different car, the 2004 Ford Pickup, 2004 Ford Excursion, and 2004 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in | ||
|---|---|---|---|---|---|
| Valve cover bolts | 10 | - | 89 | ||
| Camshaft bearing cap bolts | 10 | - | 89 | ||
| Camshaft sprocket bolts (1) | - | - | - | ||
| Cylinder head temperature sensor (CHT) | 26 | 19 | - | ||
| Camshaft position sensor bolt | 10 | - | 89 | ||
| Crankshaft position sensor bolt | 10 | - | 89 | ||
| Connecting rod bolts (1) | - | - | - | ||
| Crankshaft damper pulley bolt (1) | - | - | - | ||
| Crankshaft main bearing bolts (cross-mounted) (1) | - | - | - | ||
| Crankshaft main bearing bolts (vertical) (1) | - | - | - | ||
| Cylinder head bolts (1) | - | - | - | ||
| EGR valve to intake manifold bolts (1) | - | - | - | ||
| Exhaust manifold nuts | 25 | 18 | - | ||
| Exhaust manifold studs | 12 | 9 | - | ||
| Drive belt idler pulley bolt | 25 | 18 | - | ||
| Flywheel bolts | 80 | 59 | - | ||
| Engine front cover bolts (1-5) | 25 | 18 | - | ||
| Engine front cover bolts (6-15) | 48 | 35 | - | ||
| Fuel injection supply manifold bracket bolts | 10 | - | 89 | ||
| Heater return tube studs | 40 | 30 | - | ||
| Ignition coil bolts | 6 | - | 53 | ||
| Lower intake manifold to upper intake manifold bolts (1) | - | - | - | ||
| Upper intake manifold to cylinder head bolts (1) | - | - | - | ||
| Knock sensor | 20 | 15 | - | ||
| Remote oil cooler line to cylinder block | 10 | - | 89 | ||
| Oil cooler assembly to oil filter adapter bolts | 58 | 43 | - | ||
| Oil filter | 16 | 12 | - | ||
| Oil filter adapter bolt | 25 | 18 | - | ||
| Oil filter adapter nut | 48 | 35 | - | ||
| Oil filter adapter stud | 12 | 9 | - | ||
| Oil level indicator tube bolt | 10 | - | 89 | ||
| Oil line connector adapter assembly bolt | 25 | 18 | - | ||
| Oil pan bolts (1) | - | - | - | ||
| Oil pan drain plug | 14 | 10 | - | ||
| Oil pressure switch | 14 | 10 | - | ||
| Oil pump bolts | 10 | - | 89 | ||
| Oil pump screen and pickup tube bolts | 10 | - | 89 | ||
| Oil pump screen and pickup tube spacer | 25 | 18 | - | ||
| Oil pump screen and pickup tube spacer bolt | 25 | 18 | - | ||
| Power steering pump bolts | 25 | 18 | - | ||
| Rear main oil seal retainer bolts | 10 | - | 89 | ||
| Spark plugs | 18 | 13 | - | ||
| Thermostat housing bolts | 25 | 18 | - | ||
| Idle air control valve screws (1) | - | - | - | ||
| Throttle body spacer to intake manifold bolts (1) | - | - | - | ||
| Throttle body to throttle body spacer bolts (1) | - | - | - | ||
| Timing chain guide bolts | 10 | - | 89 | ||
| Timing chain hydraulic tensioner bolts | 25 | 18 | - | ||
| Water pump bolts | 25 | 18 | - | ||
| Water pump pulley bolts | 25 | 18 | - | ||
| EGR valve to exhaust manifold tube fittings (1) | - | - | - | ||
| 42-pin bulkhead connector bolts | 5 | - | 44 | ||
| Accelerator control splash shield bolts | 7 | - | 62 | ||
| Remote oil filter adapter line bolts (4x4 vehicles) | 10 | - | 89 | ||
| Oil cooler insert | 58 | 43 | - | ||
| Oil cooler bolt (4x4 vehicles) | 58 | 43 | - | ||
| Motor mount bolts (1) | - | - | - | ||
| Fan shroud bolts | 9 | - | 80 | ||
| Differential pressure feedback EGR system nuts | 10 | - | 89 | ||
| Exhaust-to-manifold EGR valve tube | 40-60 | 30-44 | - | ||
| Radio ignition interference capacitor nuts | 25 | 18 | - | ||
| Transmission-to-engine bolts | 48 | 35 | - | ||
| Torque converter-to-flexplate nuts | 35 | 26 | - | ||
| Generator upper mounting bracket bolts | 10 | - | 89 | ||
| Generator lower mounting bolts | 25 | 18 | - | ||
|
|||||