LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 438 (Interior Trim) >> Diagnosis And Testing >> Roof Opening Panel >> Symptom Chart >> PINPOINT TEST B: The Roof Opening Panel Leaks >> Pinpoint Test B: The Roof Opening Panel Leaks

Pinpoint Test B: The Roof Opening Panel Leaks

WARNING: This page is about a different car, the 2004 Lincoln LS. However, it is still accessible from the selected car via links, so may be relevant.
  1. B1 CHECK THE ADJUSTMENT OF THE ROOF OPENING PANEL 
    NOTE: Make sure the roof opening panel seals are not cracked or loose.
    • Check the roof opening panel seals.
    • Does the roof opening panel seal seat correctly? 
    1. Yes  : GO to B2.
    2. No  : ADJUST the roof opening panel. REFER to ROOF OPENING PANEL ALIGNMENT . REINITIALIZE the roof opening panel. REFER to ROOF OPENING PANEL MOTOR INITIALIZATION . TEST the system for normal operation.
  2. B2 CHECK THE ROOF OPENING PANEL DRAIN HOSES 
    NOTE: Make sure the roof opening panel drain hoses are not cracked, slit, pinched or obstructed.
    • Check the four roof opening panel drain hoses for correct operation.
    • Are the roof opening panel drain hoses OK? 
    1. Yes  : GO to B3.
    2. No  : REPAIR the roof opening panel drain hose(s). TEST the system for normal operation.
  3. B3 CHECK THE ROOF OPENING PANEL DRAIN HOSE ATTACHMENT POINTS 
    NOTE: Make sure the roof opening panel drain hose attachment points are not damaged or obstructed.
    • Check the roof opening panel drain hose attachment points for correct attachment.
    • Are the attachment points OK? 
    1. Yes  : GO to B4.
    2. No  : REPAIR or INSTALL a new roof opening panel. REFER to ROOF OPENING PANEL . TEST the system for normal operation.
  4. B4 CHECK THE ROOF OPENING PANEL WATER TROUGH CONDITION 
    • Check the roof opening panel water trough and the water trough seal for damage.
    • Are the roof opening panel water trough and seal OK? 
    1. Yes  : GO to B5.
    2. No  : REPAIR the roof opening panel water trough and seal. REINITIALIZE the roof opening panel. REFER to ROOF OPENING PANEL MOTOR INITIALIZATION . TEST the system for normal operation.
  5. B5 CHECK THE CONDITION OF THE ROOF OPENING PANEL 
    • Check the roof opening panel assembly for damage that may cause the roof opening panel seal to seat incorrectly.
    • Is the roof opening panel assembly OK? 
    1. Yes  : INSTALL a new roof opening panel assembly. REFER to ROOF OPENING PANEL . TEST the system for normal operation.
    2. No  : REPAIR or INSTALL a new roof opening panel assembly. REFER to ROOF OPENING PANEL . TEST the system for normal operation.
scientia non olet · About LEMON Manuals