LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 371 (Steering System - General Information) >> Diagnosis And Testing >> Component Tests >> Turning Effort Test

Turning Effort Test

WARNING: This page is about a different car, the 2002 Ford RV Cutaway, 2002 Ford Econoline, 2002 Ford E550 Super Duty, 2002 Ford E450 Super Duty, and 2002 Ford Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Make sure that the front wheels are properly aligned and the tire pressure is correct before checking the effort.
  1. Park the vehicle on dry concrete and set the parking brake.
  2. Insert a thermometer into the power steering oil reservoir (3A697).
    3. CAUTION: Do not hold the steering wheel against the stops for more than three to five seconds at a time. Damage to the power steering pump will occur.
  3. Idle the engine for two to three minutes. Turn the steering wheel from stop to stop several times to warm the fluid to 50-60°C (122-140°F).
  4. With the engine running, attach the Spring Scale to the rim of the steering wheel.
  5. Measure the pull required to turn the steering wheel one complete revolution in each direction. Refer to Steering Wheel Turning Effort under General Specifications .
scientia non olet · About LEMON Manuals