PINPOINT TEST HX: Evaporative Emission (EVAP) System and Monitor: Introduction

WARNING: This page does not describe the selected car, but rather 35 other vehicles, including the 2007 Mercury Mountaineer, 2007 Mercury Monterey, 2007 Mercury Montego, 2007 Mercury Milan, and 2007 Mercury Mariner. However, it is still accessible from the selected car via links, so may be relevant.

WARNING: Crown Victoria Police Interceptor vehicles equipped with fire suppression system, refer to FIRE SUPPRESSION SYSTEM article for Important Safety Warnings. Failure to follow these instructions may result in personal injury.

WARNING: Before repairing or installing a new component in the fuel system, reduce the possibility of injury or fire by following the warning, caution, and handling directions in pinpoint test HC. Failure to follow these instructions may result in personal injury.

NOTE: Use this pinpoint test only when directed here.

The use of a soap solution around the fuel filler cap or the use of the hydrocarbon emission analyzer to determine an evaporative emission system leak is not recommended. The mandatory Rotunda Evaporative Emission System Leak Tester for On Board Diagnostic (OBD) (including the ultrasonic tester) and the Rotunda Vacutec 522 Leak Detector Smoke Machine are the only devices to be used at this time for evaporative emission system leak detection.

When using the smoke machine, the fuel level in the fuel tank must be less than 85% full.

This pinpoint test is intended to diagnose the following:

canister vent (CV) solenoid (9F945)
fuel filler cap (9030)
fuel tank pressure (FTP) sensor (9C052)
EVAP canister purge (EVAPCP) valve (9C915). Also known as the vapor management valve (VMV).
EVAP system leaks using the Rotunda Vacutec Leak Detector Smoke Machine.
harness circuits: B+, CV, EVAPCP, FTP, FTPREF, SIGRTN, VPWR, VREF and CASE GND
powertrain control module (PCM) (12A650)

For additional information on the EVAP system, refer to EVAPORATIVE EMISSION (EVAP) SYSTEMS , or the appropriate EVAPORATIVE EMISSIONS article.

For applications that use the engine off natural vacuum (EONV) EVAP leak check monitor, KAPWR provides voltage to the CV solenoid instead of VPWR.

Fig 1: Canister Vent (CV) Solenoid Connector

Vehicle	Connector	Pin	Circuit
Explorer, Explorer Sport Trac, Mountaineer	A	2 1	KAPWR CANV
Focus, Mustang, Taurus	A	2 1	CANV VPWR
All other vehicles	A	1 2	KAPWR CANV

Fig 2: EVAP Canister Purge (EVAPCP) Valve Connector

Pin	Circuit
2	EVAPCP (EVAP Canister Purge)
1	VPWR (Vehicle Power)

For applications that use the engine off natural vacuum (EONV) EVAP leak check monitor, FTPREF provides voltage to the FTP sensor instead of VREF.

Fig 3: Fuel Tank Pressure (FTP) Sensor Connector - A

Courtesy of FORD MOTOR CO.

Fig 4: Fuel Tank Pressure (FTP) Sensor Connector - B

Courtesy of FORD MOTOR CO.

Vehicle	Connector	Pin	Circuit
E-Series tank design, F-Super Duty tank design	A	3 1 2	FTP FTPREF SIGRTN
Focus, Mustang	B	3 2 1	FTP SIGRTN VREF
Taurus	A	3 2 1	FTP SIGRTN VREF
All other vehicles	B	3 1 2	FTP FTPREF SIGRTN

Powertrain Control Module (PCM) Connector

For PCM connector views or reference values, refer to the REFERENCE VALUES article.

Vehicle	Connector	Pin	Circuit
E-Series, F-Super Duty	170 Pin	B13 B3 B40 B41 E57 E1	CANV FTP FTPREF SIGRTN VREF EVAPCP
Edge, MKX	190 Pin	B61 B44 B29 B58 B29 B50	CANV FTP FTPREF SIGRTN VREF EVAPCP
Escape, Mariner	150 (50-50-50) Pin	B13 B9 B40 B41 E40 B34	CANV FTP FTPREF SIGRTN VREF EVAPCP
Expedition, Navigator	140 Pin	B61 B44 B29 B58 E57 B50	CANV FTP FTPREF SIGRTN VREF EVAPCP
F-150, Mark LT	190 Pin	B61 B44 B65 B58 B29 B50	CANV FTP FTPREF SIGRTN VREF EVAPCP
Five Hundred, Freestyle, Montego	150 (50-50-50) Pin	B13 B3 B40 B41 E40 E28	CANV FTP FTPREF SIGRTN VREF EVAPCP
Focus	150 (50-50-50) Pin	B13 B9 B41 E40 B34	CANV FTP SIGRTN VREF EVAPCP
Freestar/Monterey	104 Pin	67 62 59 91 90 56	CANV FTP FTPREF SIGRTN VREF EVAPCP
Fusion, Milan, MKZ	140 Pin	B61 B44 B29 B58 B33 B4	CANV FTP FTPREF SIGRTN VREF EVAPCP
Mustang	170 Pin	B13 B3 B41 B40 E6	CANV FTP SIGRTN VREF EVAPCP
Taurus	104 Pin	67 62 91 90 56	CANV FTP SIGRTN VREF EVAPCP
All other vehicles	170 Pin	B13 B3 B40 B41 E57 E6	CANV FTP FTPREF SIGRTN VREF EVAPCP