LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 2410 (Engine Mechanical - 3.0L (4V)) >> In-Vehicle Repair >> Cylinder Head - RH >> Installation

Cylinder Head - RH: Installation

WARNING: This page is about a different car, the 2010 Mercury Mariner and 2010 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.
    NOTE: Do not use metal scrapers, wire brushes, power abrasive discs or other abrasive means to clean the sealing surfaces. These tools cause scratches and gouges which make leak paths.
  1. Use a plastic scraping tool to remove all traces of the head gasket.
    • Clean all surfaces with metal surface prep.
  2. Position a new gasket and the cylinder head.
  3. NOTE: New cylinder head bolts must be installed. They are a torque-to-yield design and cannot be reused.
  4. Install the bolts and tighten in 6 stages in the sequence shown.
    • Stage 1: Tighten to 40 Nm (30 lb-ft).
    • Stage 2: Tighten 90 degrees.
    • Stage 3: Loosen one full turn.
    • Stage 4: Tighten to 40 Nm (30 lb-ft).
    • Stage 5: Tighten 90 degrees.
    • Stage 6: Tighten 90 degrees.
      Fig 1: Identifying Cylinder Head Bolts In Sequence
      G06389374Courtesy of FORD MOTOR CO.
  5. Install the RH exhaust manifold. For additional information, refer to EXHAUST MANIFOLD - RH .
  6. NOTE: The hydraulic lash adjusters must be installed in their original positions. If not reassembled in their original positions, severe engine damage may occur.
  7. Install the hydraulic lash adjusters.
    • Lubricate the hydraulic lash adjusters with clean engine oil.
  8. NOTE: The camshaft roller followers must be installed in their original positions. If not reassembled in their original positions, severe engine damage may occur.
  9. Install the camshaft roller followers.
    • Lubricate the camshaft roller followers with clean engine oil.
  10. Install the RH camshafts. For additional information, refer to VALVE TRAIN COMPONENTS - EXPLODED VIEW  and CAMSHAFTS - RH .
  11. Install the coolant pump housing. For additional information, refer to COOLANT PUMP HOUSING -- 3.0L (4V) .
  12. Install the lower intake manifold. For additional information, refer to LOWER INTAKE MANIFOLD .