240,000 km (150,000 mi)
WARNING: This page is about a different car, the 2010 Mercury Milan, 2010 Lincoln MKZ, and 2010 Ford Fusion. However, it is still accessible from the selected car via links, so may be relevant.
- Change engine oil and install a new oil filter.
- Perform multi-point inspection (recommended).
- Rotate tires, inspect tires for wear, measure tread depth and inspect wheel ends for end play and noise. Vehicles with dual rear wheels should only be rotated if unusual wear is noted. For vehicles with different front-to-rear tire pressures, the tire pressure must be adjusted and the tire pressure sensor training must be done.
- Install a new cabin air filter (if equipped).
- Install a new engine air filter (except Focus with PZEV engine).
- Install new climate controlled seat cushion filters (if equipped).
- Install a new fuel filter on Crown Victoria, Grand Marquis, Town Car and Mustang (not required for Fusion, Milan, MKZ, Edge, MKX, Taurus, Focus, E-Series, Expedition and Navigator with short wheelbase, F-150, Flex, MKS, Escape, Mariner, F-Series [non-Super Duty] and Transit Connect).
- Change automatic transmission fluid and filter (except for 6F35, 6F50, AWF-21, FNR5 and TorqShift® transmissions).
- Change manual transmission fluid (if equipped).
- Change transfer case fluid, 4WD (if equipped).
- Change front differential fluid, 4WD (if equipped).
- Replace rear axle lubricant on all RWD vehicles.
- Inspect and lubricate control arms, steering linkage, steering ball joints, U-joints and driveshaft with zerk fittings (if equipped).
- Inspect halfshaft boots (if equipped).
- Inspect and lubricate 4WD front axle shaft U-joints (if equipped).
- Install new front wheel bearings (if not sealed units).
- Inspect brake pads, rotors, brake linings, drums, brake lines, hoses and parking brake system.
- Change engine coolant.
- Inspect engine cooling system and hoses.
- Install a new accessory drive belt(s) (if a new belt(s) has not been installed within the last 160,000 km [100,000 mi]).
- Inspect exhaust system and heat shields.
- Check the rear spring U-bolt nuts for correct torque every 24,000 km (15,000 mi) (Transit Connect).