Torque Specifications
WARNING: This page is about a different car, the 2007 Mercury Mariner and 2007 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in |
|---|---|---|---|
| 42-pin electrical connector bolt | 10 | - | 89 |
| A/C compressor mounting bolts | 25 | 18 | - |
| A/C manifold tube bolt | 20 | 15 | - |
| Accelerator cable bracket bolt | 10 | - | 89 |
| Accelerator cable bracket nuts | 5 | - | 44 |
| Accelerator cable snow shield retainer | 10 | - | 89 |
| Accessory drive belt idler pulley bolt | 25 | 18 | - |
| Bellhousing-to-engine bolts | 48 | 35 | - |
| Blocker heater | 21 | 15 | - |
| Camshaft bearing cap boltsa | - | - | - |
| Camshaft sprocket bolts | 72 | 53 | - |
| Catalytic converter bracket bolts | 25 | 18 | - |
| Catalytic converter-to-cylinder head nuts | 47 | 35 | - |
| Coil-on-plug retaining stud bolts | 8 | - | 71 |
| Coolant outlet bolts | 10 | - | 89 |
| Coolant pump bolts | 10 | - | 89 |
| Coolant pump pulley bolts | 20 | 15 | - |
| Coolant vent tube bracket nut | 6 | - | 53 |
| Crankshaft position (CKP) sensor bolts | 7 | - | 62 |
| Crankshaft pulley bolta | - | - | - |
| Crankshaft rear oil seal retainer boltsa | - | - | - |
| Cylinder head boltsa | - | - | - |
| Cylinder head temperature (CHT) sensor | 12 | 9 | - |
| Driveshaft bolts | 20 | 15 | - |
| Engine front cover boltsa | - | - | - |
| Engine front cover-to-oil pan boltsa | - | - | - |
| Engine mount bolts | 55 | 41 | - |
| Engine mount bracket bolt | 115 | 85 | - |
| Engine mount bracket nuts | 115 | 85 | - |
| Engine roll-restrictor bolts | 115 | 85 | - |
| Engine support crossmember bolts | 90 | 66 | - |
| Engine support crossmember nut | 175 | 129 | - |
| Engine timing plug bolt | 20 | 15 | - |
| Engine-to-bellhousing bolts | 48 | 35 | - |
| Exhaust gas recirculation (EGR) tube | 55 | 41 | - |
| Exhaust gas recirculation (EGR) valve assembly bolts | 20 | 15 | - |
| Exhaust manifold nuta | - | - | - |
| Flexplate boltsa | - | - | - |
| Flywheel boltsa | - | - | - |
| Fuel rail bolts | 23 | 17 | - |
| Generator electrical connection nut | 6 | - | 53 |
| Generator lower air duct bolt | 4 | - | 35 |
| Generator mounting bolts | 47 | 35 | - |
| Generator shield nut | 20 | 15 | - |
| Ground wire bolt | 10 | - | 89 |
| Halfshaft support bracket bolts | 40 | 30 | - |
| Heat shield bolts | 10 | - | 89 |
| Intake manifold bolts | 18 | 13 | - |
| Knock sensor (KS) bolt | 20 | 15 | - |
| Laterial support crossmember bolts | 115 | 85 | - |
| LH transaxle mount bolt | 103 | 76 | - |
| Oil filter adapter bolts | 25 | 18 | - |
| Oil level indicator tube bolt | 10 | - | 89 |
| Oil pan-to-bellhousing boltsa | - | - | - |
| Oil pan boltsa | - | - | - |
| Oil pan drain plug | 28 | 21 | - |
| Oil pressure sender | 15 | 11 | - |
| Oil pump-to-engine block boltsa | - | - | - |
| Oil pump drive chain guide bolts (early build) | 10 | - | 89 |
| Oil pump drive chain tensioner shoulder bolts | 10 | - | 89 |
| Oil pump screen and pickup tube bolts | 10 | - | 89 |
| Oil pump sprocket bolt | 25 | 18 | - |
| Output shaft speed (OSS) sensor bolt | 13 | 10 | - |
| Power distribution box (PDB) cable nuts | 12 | 9 | - |
| Power steering pump mounting bolts | 25 | 18 | - |
| Power steering tube bracket nut | 6 | - | 53 |
| Powertrain control module (PCM) wiring connector bolt | 6 | - | 53 |
| Pressure plate bolts | 29 | 21 | - |
| Radio capacitor bolt | 20 | 15 | - |
| Rear main seal mounting plate bolts | 10 | - | 89 |
| Rear transaxle mount bolt | 115 | 85 | - |
| RH splash shield bolts | 9 | - | 80 |
| Spark plug | 12 | 9 | - |
| Thermostat housing bolts | 10 | - | 89 |
| Timing chain guide bolts | 10 | - | 89 |
| Timing chain tensioner bolts | 10 | - | 89 |
| Torque converter-to-flywheel nuts | 35 | 26 | - |
| Torque converter nuts | 35 | 26 | - |
| Transaxle control cable bracket bolt | 19 | 14 | - |
| Transmission bracket bolt | 13 | 10 | - |
| Transmission fluid cooler tube | 23 | 17 | - |
| Upper engine bracket-to-power transfer unit (PTU) bolts | 45 | 33 | - |
| Valve cover boltsa | - | - | - |
a Refer to procedure for specification.