LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 1892 (Transfer Case - Four Wheel Drive (4WD) Systems -- F250-F550 Super Duty) >> Diagnostic Tests >> Four Wheel Drive (4WD) Systems - Electronic Shift >> Pinpoint Tests >> Pinpoint Test O: Straightline Driveline Wind-up >> Pinpoint Test O: STRAIGHTLINE Driveline Wind-Up

Pinpoint Test O: STRAIGHTLINE Driveline Wind-Up

WARNING: This page is about a different car, the 2007 Ford Pickup, 2007 Ford F550 Super Duty, 2007 Ford F450 Super Duty, and 2007 Ford Cab & Chassis. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: 4x4 high/low (4H/4L) is not intended for driving on hard/dry surfaces.
  1. O1 VERIFY THE CONCERN 
    • Drive the vehicle and shift from 2H to 4H. There should be minimal wind-up in 4H mode during straight-line maneuvers, (wind-up in turns is normal; 4x4 high/low is not intended for driving on hard/dry surfaces).
    • Is wind-up present? 
    1. YES  : Go to  O2.
    2. NO  : RETURN the vehicle to the customer and ADVISE about correct 4x4 usage and normal vehicle behavior.
  2. O2 CHECK FOR MATCHING WHEEL AND TIRE SIZES 
    • Check each of the 4 tire/wheel sizes.
    • Do the 4 wheels and tires match? 
    1. YES  : Go to  O3.
    2. NO  : ADVISE the customer that four wheel drive (4WD) systems require 4 matched, correctly inflated and correctly maintained tires to operate correctly.
  3. O3 CHECK TIRE WEAR 
    • Check each of the 4 tires for wear.
    • Are the 4 tires worn evenly? 
    1. YES  : Go to  O4.
    2. NO  : ADVISE the customer that 4WD systems require 4 matched, correctly inflated and correctly maintained tires to operate correctly.
  4. O4 CHECK TIRE INFLATION PRESSURE 
    • Check the inflation pressure in each tire. Refer to vehicle certification label.
    • Are the tire inflation pressures correct? 
    1. YES  : Go to  O5.
    2. NO  : ADJUST the tire pressure as necessary. TEST the vehicle for normal operation. ADVISE the customer that 4WD systems require 4 matched, correctly inflated, correctly maintained tires to operate correctly.
  5. O5 CHECK THE FRONT AND REAR AXLE RATIOS 
    1. YES  : RETURN the vehicle to the customer and ADVISE about correct 4WD system operation and normal vehicle behavior.
    2. NO  : CHECK the vehicle identification label. INSTALL the correct axle(s). REFER to DRIVELINE SYSTEM - GENERAL INFORMATION article.
scientia non olet · About LEMON Manuals