LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 1810 (Transfer Case - Four Wheel Drive (4WD) Systems - F-150 & Mark LT) >> Diagnostic Tests >> Four Wheel Drive (4WD) Systems - All Wheel Drive (AWD) >> Pinpoint Tests >> Pinpoint Test V: Straightline Driveline Wind-up >> Pinpoint Test V: STRAIGHTLINE Driveline Wind-Up

Pinpoint Test V: STRAIGHTLINE Driveline Wind-Up

WARNING: This page is about a different car, the 2007 Lincoln Mark LT and 2007 Ford Pickup. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: All wheel drive (AWD) LOCKED mode is not intended for driving on hard/dry surfaces.
  1. V1 VERIFY THE CONCERN 
    • Drive the vehicle and shift from AWD AUTO to 4H. There should be minimal wind-up in 4H mode during straight line maneuvers, (wind-up in turns is normal; AWD LOCKED is not intended for driving on hard/dry surfaces).
    • Is excessive wind-up present? 
    1. YES  : Go to  V2.
    2. NO  : RETURN the vehicle to the customer. ADVISE about correct 4WD system operation and normal vehicle behavior.
  2. V2 CHECK FOR MATCHING WHEEL AND TIRE SIZES 
    • Check the wheel and tire sizes.
    • Do the 4 wheel and tire sizes match? 
    1. YES  : Go to  V3.
    2. NO  : ADVISE the customer that 4WD systems require 4 matched, correctly inflated, correctly maintained tires to operate correctly.
  3. V3 CHECK TIRE WEAR 
    • Check each of the 4 tires for wear.
    • Are the 4 tires worn evenly? 
    1. YES  : Go to  V4.
    2. NO  : ADVISE the customer that 4WD systems require 4 matched, correctly inflated, correctly rotated tires to operate correctly.
  4. V4 CHECK TIRE INFLATION PRESSURE 
    • Check the inflation pressure in each tire. Refer to vehicle certification label.
    • Are the tire inflation pressures correct? 
    1. YES  : Go to  V5.
    2. NO  : ADJUST the tire pressure as necessary. TEST the vehicle for normal operation. ADVISE the customer that 4WD systems require 4 matched, correctly inflated, correctly maintained tires to operate correctly.
  5. V5 CHECK THE FRONT AND REAR AXLE RATIOS 
    1. YES  : RETURN the vehicle to the customer and ADVISE about correct 4WD usage and normal vehicle behavior.
    2. NO  : CHECK the vehicle identification label. INSTALL the correct axle(s). REFER to DRIVELINE SYSTEM - GENERAL INFORMATION article.
scientia non olet · About LEMON Manuals