Recommended Procedure:
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2007 Ford RV Cutaway, 2007 Ford Pickup, 2007 Ford F550 Super Duty, 2007 Ford F450 Super Duty, and 2007 Ford Econoline. However, it is still accessible from the selected car via links, so may be relevant.
This test determines if the injector circuits and solenoids are electrically operating without fault. All injectors will first click together for approximately 2 seconds, then each injector will click for approximately 1 second in numerical order (1 through 8). If a fault is detected, a DTC outputs on the data link at the end of the test when requested by a scan tool. Only a hard fault DTC is displayed.
Connect the scan tool. Turn off all accessories. If vehicle is equipped with a power take-off (PTO) system or auxiliary idle control, it must be turned off to carry out the self-test.
- Carry out the necessary vehicle preparation and a visual inspection. Refer to QUICK TEST OPERATION .
- Refer to the scan tool operating manual for instructions.
- Key ON, engine OFF.
- Follow the operating instructions from the diagnostic menu.
- Carry out the KOEO Injector Electrical Self-Test (Click Test).
- Record the DTCs and refer to the appropriate pinpoint test to continue diagnosis.