LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 1778 (Rear View Mirrors) >> Diagnosis And Testing >> Rear View Mirrors >> Inspection and Verification

Inspection and Verification

WARNING: This page is about a different car, the 2006 Mercury Milan, 2006 Lincoln Zephyr, and 2006 Ford Fusion. However, it is still accessible from the selected car via links, so may be relevant.
  1. Verify the customer concern.
  2. Inspect the components of the exterior mirror system to determine if any of the following mechanical or electrical concerns apply:
    VISUAL INSPECTION CHART

    Mechanical Electrical
    • Exterior mirrors
    • Exterior mirror control switch
    • Auto-dimming interior mirror
    • Smart junction box (SJB) fuse(s):
      • 9 (10A)
      • 12 (7.5A)
      • 20 (7.5A)
    • Circuitry
    • Driver seat module (DSM)
    • Driver door module (DDM)
    • Loose or corroded connections
  3. If the vehicle is equipped with memory exterior mirrors and the concern remains after the inspection, connect the diagnostic tool to the data link connector (DLC) located beneath the instrument panel. Select the vehicle to be tested from the diagnostic tool menu. If the diagnostic tool does not communicate with the vehicle:
    • Check to make sure the program card is correctly installed.
    • Check the connections to the vehicle.
    • Check the ignition switch position.
  4. If the diagnostic tool still does not communicate with the vehicle, refer to the diagnostic tool manual.
  5. Carry out the DATA LINK DIAGNOSTICS test. If the diagnostic tool responds with:
    • CAN, UBP or ISO circuit fault; All ECUs NO RESP/NOT EQUIP, refer to MODULE COMMUNICATIONS NETWORK .
    • NO RESPONSE/NOT EQUIPPED for DSM, go to MULTIFUNCTION ELECTRONIC CONTROL MODULES .
    • SYSTEM PASSED for the DSM, retrieve and record the continuous diagnostic trouble codes (DTCs), erase the continuous DTCs and carry out self-test diagnostics for the DSM.
  6. If the DTCs retrieved are related to the concern, go to DSM DIAGNOSTIC TROUBLE CODE (DTC) INDEX .
  7. If DTCs are retrieved that are not found in the following DSM Diagnostic Trouble Code (DTC) Index, refer to the DIAGNOSTIC TROUBLE CODE (DTC) CHART .
  8. If an obvious cause for an observed or reported concern is found, correct the cause (if possible) before proceeding to the next step.
  9. If no DTCs related to the concern are retrieved, refer to the SYMPTOM CHART .
DRIVER DOOR MODULE (DDM) DIAGNOSTIC TROUBLE CODE (DTC) INDEX

DTC Description Action
B1234 Mirror Switch Invalid Code GO to PINPOINT TEST E .
B1317 Battery Voltage High REFER to CHARGING SYSTEM - GENERAL INFORMATION .
B1318 Battery Voltage Low REFER to CHARGING SYSTEM - GENERAL INFORMATION .
B1342 ECU Is Faulted INSTALL a new module. REFER to MULTIFUNCTION ELECTRONIC CONTROL MODULES .
B1530 Memory Set Switch Circuit Short to Ground DSM GO to PINPOINT TEST F .
B1534 Memory 1 Switch Circuit Short to Ground GO to PINPOINT TEST F .
B1538 Memory 2 Switch Circuit Short to Ground GO to PINPOINT TEST F .
B1667 Mirror Driver Up/Down Motor Stalled GO to PINPOINT TEST E .
B1668 Mirror Driver Right/Left Motor Stalled GO to PINPOINT TEST E .
B2084 Memory Set Indicator Short To Ground REPAIR circuit CPS55 (YE) for a short to ground. TEST the system for normal operation.
B2143 Non Volitile Memory Failure INSTALL a new module. REFER to MULTIFUNCTION ELECTRONIC CONTROL MODULES .
B2223 Driver Mirror Drive Circuit Failure GO to PINPOINT TEST E .
B2320 Driver Mirror Horizontal Feedback Potentiometer Circuit Failure GO to PINPOINT TEST F .
B2322 Driver Mirror Horizontal Feedback Potentiometer Circuit Short to Battery GO to PINPOINT TEST F .
B2324 Driver Mirror Vertical Feedback Potentiometer Circuit Failure GO to PINPOINT TEST F .
B2326 Driver Mirror Vertical Feedback Potentiometer Circuit Short to Battery GO to PINPOINT TEST F .
U2050 No Application Code Present INSTALL a new module. REFER to MULTIFUNCTION ELECTRONIC CONTROL MODULES .
DRIVER SEAT MODULE (DSM) DIAGNOSTIC TROUBLE CODE (DTC) INDEX

DTC Description Action
B1669 Mirror Passenger Up/Down Motor Stalled GO to PINPOINT TEST E .
B1670 Mirror Passenger Right/Left Motor Stalled GO to PINPOINT TEST E .
B2224 Passenger Mirror Drive Circuit Failure GO to PINPOINT TEST E .
B2312 Passenger Mirror Horizontal Feedback Potentiometer Circuit Failure GO to PINPOINT TEST F .
B2314 Passenger Mirror Horizontal Feedback Potentiometer Circuit Short to Battery GO to PINPOINT TEST F .
B2316 Passenger Mirror Vertical Feedback Potentiometer Circuit Failure GO to PINPOINT TEST F .
B2318 Passenger Mirror Vertical Feedback Potentiometer Circuit Short to Battery GO to PINPOINT TEST F .
scientia non olet · About LEMON Manuals