Torque Specifications
WARNING: This page is about a different car, the 2006 Mercury Milan, 2006 Lincoln Zephyr, and 2006 Ford Fusion. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS
| Description | Nm | lb-ft | lb-in | ||
|---|---|---|---|---|---|
| A/C compressor bolts | 25 | 18 | - | ||
| A/C compressor bracket bolts | 25 | 18 | - | ||
| A/C manifold bolt | 15 | 11 | - | ||
| A/C tube connection bolts | 8 | - | 71 | ||
| A/C tube retaining bolts | 8 | - | 71 | ||
| Accessory drive belt tensioner bolt | 45 | 33 | - | ||
| Accessory drive belt idler (grooved) pulley bolt | 25 | 18 | - | ||
| Accessory drive belt idler (non-grooved) pulley bolt | 48 | 35 | - | ||
| Block heater | 41 | 30 | - | ||
| Camshaft bearing cap bolts(1) | - | - | - | ||
| Camshaft thrust bearing cap bolts(1) | - | - | - | ||
| Camshaft oil seal retainer bolts | 10 | - | 89 | ||
| Camshaft position (CMP) sensor electrical connector bracket bolt | 12 | 9 | - | ||
| Catalyst monitor sensor bracket bolt | 12 | 9 | - | ||
| Catalytic converter heat shield bolts | 11 | 8 | - | ||
| Catalytic converter studs | 12 | 9 | - | ||
| Catalytic converter nuts | 20 | 15 | - | ||
| Catalytic converter-to-engine bracket bolts | 35 | 26 | - | ||
| Catalytic converter bracket-to-converter bolts | 20 | 15 | - | ||
| Coolant bypass tube nuts | 20 | 15 | - | ||
| Coolant pump drive pulley cover | 6 | - | 53 | ||
| Coolant pump bolts | 10 | - | 89 | ||
| Crankshaft pulley bolt(1) | - | - | - | ||
| Crankcase cover bolts | 10 | - | 89 | ||
| Cylinder head bolts(1) | - | - | - | ||
| Exhaust gas recirculation (EGR) tube nuts | 40 | 30 | - | ||
| EGR valve bolts | 25 | 18 | - | ||
| Engine front cover bolts(1) | - | - | - | ||
| Engine oil filter(1) | - | - | - | ||
| Engine cover ball studs | 4 | - | 35 | ||
| Engine mount bracket bolt | 115 | 85 | - | ||
| Engine mount bracket nuts | 63 | 46 | - | ||
| Engine mount damper bolt | 23 | 17 | - | ||
| Engine mount nut and bolts | 55 | 41 | - | ||
| Engine roll-restrictor bolts | 90 | 66 | - | ||
| Flexplate bolts | 80 | 59 | - | ||
| Generator bolts and stud bolt | 48 | 35 | - | ||
| Generator B+ terminal nut | 6 | - | 53 | ||
| Ground wire-to-engine mount bracket bolt | 10 | - | 89 | ||
| Ground wire-to-transaxle bolt | 12 | 9 | - | ||
| Halfshaft carrier bearing bracket bolts | 55 | 41 | - | ||
| Ignition coil-on-plug bolts | 7 | - | 62 | ||
| Intermediate steering shaft bolt | 23 | 17 | - | ||
| Knock sensor (KS) bolt | 20 | 15 | - | ||
| Lower ball joint nuts | 200 | 148 | - | ||
| Lower control arm-to-strut through bolt | 103 | 76 | - | ||
| Lower intake manifold bolts | 10 | - | 89 | ||
| Oil level indicator tube stud bolt | 9 | - | 80 | ||
| Oil pan baffle nuts(1) | - | - | - | ||
| Oil pan bolts and stud bolts(1) | - | - | - | ||
| Oil pan-to-engine front cover bolts | 25 | 18 | - | ||
| Oil pan-to-transaxle bolts | 48 | 35 | - | ||
| Oil pan drain plug | 26 | 19 | - | ||
| Oil pressure sender | 14 | 10 | - | ||
| Oil pump bolts(1) | - | - | - | ||
| Oil pump screen and pickup tube bolts | 10 | - | 89 | ||
| Oil separator cover bolts | 10 | - | 89 | ||
| Power steering pump bolts | 25 | 18 | - | ||
| Power steering pressure (PSP) tube bracket-to-cylinder head bolt | 9 | - | 80 | ||
| PSP tube bracket-to-reservoir bolt | 9 | - | 80 | ||
| PSP tube bracket-to-steering gear bolt | 9 | - | 80 | ||
| Power steering reservoir nuts | 9 | - | 80 | ||
| PSP tube banjo bolts | 35 | 26 | - | ||
| Radio frequency interference capacitor nut | 6 | - | 53 | ||
| Spark plugs | 15 | 11 | - | ||
| Starter motor bolts | 27 | 20 | - | ||
| Starter B+ terminal nut | 12 | 9 | - | ||
| Starter S terminal nut | 5 | - | 44 | ||
| Subframe nuts | 150 | 111 | - | ||
| Subframe bracket bolts | 103 | 76 | - | ||
| Sway bar link nuts | 40 | 30 | - | ||
| Throttle body bolts | 10 | - | 89 | ||
| Tie rod end nuts | 48 | 35 | - | ||
| Timing chain tensioner bolts | 25 | 18 | - | ||
| Torque converter-to-flexplate nuts | 36 | 27 | - | ||
| Transaxle control cable bracket | 8 | - | 71 | ||
| Transaxle-to-engine bolts | 48 | 35 | - | ||
| Transaxle mount bolts | 90 | 66 | - | ||
| Upper intake manifold bolts(1) | - | - | - | ||
| Vacuum tube bracket | 10 | - | 89 | ||
| Variable camshaft timing (VCT) actuator bolts(1) | - | - | - | ||
| VCT assembly bolts | 25 | 18 | - | ||
| Valve cover bolts and stud bolts(1) | - | - | - | ||
| Windshield washer bottle and A/C tube retaining bolt | 7 | - | 62 | ||
|
|||||