Torque Specifications
WARNING: This page is about a different car, the 2006 Mercury Mariner and 2006 Ford Escape. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS
| Description | N.m | lb-ft | lb-in | ||
|---|---|---|---|---|---|
| Camshaft bearing caps(1) | - | - | - | ||
| Coolant outlet bolts | 10 | - | 89 | ||
| Oil pan bolts(1) | - | - | - | ||
| Oil pump-to-engine block bolts(1) | - | - | - | ||
| Cylinder head bolts(1) | - | - | - | ||
| Intake manifold bolts | 18 | 13 | - | ||
| Flywheel bolt(1) | - | - | - | ||
| Crankshaft pulley bolt(1) | - | - | - | ||
| Crankshaft position (CKP) sensor | 7 | - | 62 | ||
| Rear crankshaft oil seal retainer(1) | - | - | - | ||
| A/C compressor mounting bolts | 25 | 18 | - | ||
| Oil pump sprocket bolt | 25 | 18 | - | ||
| Knock sensor (KS) | 20 | 15 | - | ||
| Engine mount bracket-to-mount bolt | 115 | 85 | - | ||
| Engine mount bracket-to-engine nuts | 115 | 85 | - | ||
| Engine mount bolts (W500233-S439) | 48 | 35 | - | ||
| Engine roll-restrictor bolts | 90 | 66 | - | ||
| Engine-to-transmission bolts | 48 | 35 | - | ||
| Block-off plate bolts | 25 | 18 | - | ||
| Powertrain control module (PCM) wiring harness retaining nut | 6 | - | 53 | ||
| PCM ground strap retaining nut | 6 | - | 53 | ||
| Coolant pump bolts | 10 | - | 89 | ||
| Engine front cover bolts(1) | - | - | - | ||
| Camshaft sprocket bolt | 72 | 53 | - | ||
| Valve cover bolts | 10 | - | 89 | ||
| Exhaust gas recirculation (EGR) valve assembly bolts | 20 | 15 | - | ||
| Thermostat housing bolts | 10 | - | 89 | ||
| Oil pump screen and cover assembly | 10 | - | 89 | ||
| Exhaust manifold studs | 17 | 13 | - | ||
| Catalytic converter-to-cylinder head nuts | 47 | 35 | - | ||
| Coolant pump pulley bolts | 20 | 15 | - | ||
| A/C compressor mounting bolts | 48 | 35 | - | ||
| Oil level indicator tube bolt | 10 | - | 89 | ||
| Oil pressure sender | 15 | 11 | - | ||
| A/C manifold tube bolt | 20 | 15 | - | ||
| A/C tube bracket nut | 10 | - | 89 | ||
| Oil drain plug | 28 | 21 | - | ||
| Oil pump chain tensioner bolts | 10 | - | 89 | ||
| Oil pump chain guide bolts | 10 | - | 89 | ||
| Timing chain guide bolts | 10 | - | 89 | ||
| Timing chain tensioner bolts | 10 | - | 89 | ||
| Crankcase vent oil separator bolts | 10 | - | 89 | ||
| Oil filter adapter bolts | 25 | 18 | - | ||
| Air cleaner outlet tube clamps | 3 | - | 27 | ||
| Manifold absolute pressure (MAP) sensor retainer nut | 10 | - | 89 | ||
| Motor electronics coolant pump bolts | 20 | 15 | - | ||
| Coil-on-plug retaining stud bolts | 10 | - | 89 | ||
| Engine timing plug bolt | 20 | 15 | - | ||
| Belt tensioner bolt | 25 | 18 | - | ||
| Oil filter cup | 33 | 24 | - | ||
| Oil pan-to-bellhousing bolts | 48 | 35 | - | ||
| Rear main seal mounting plate bolts | 10 | - | 89 | ||
| Camshaft position (CMP) sensor bolt | 20 | 15 | - | ||
| Cylinder head temperature (CHT) sensor | 12 | 9 | - | ||
| Spark plug | 12 | 9 | - | ||
| Fuel rail bolts | 10 | - | 89 | ||
| Damper bolts | 29 | 21 | - | ||
| Transaxle mount nuts | 90 | 66 | - | ||
| Transaxle mount bolt | 103 | 76 | - | ||
|
|||||