LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 1096 (Charging System - General Information) >> Diagnosis And Testing >> Charging System >> Component Tests >> Generator On-Vehicle Tests

Generator On-Vehicle Tests

WARNING: This page is about a different car, the 2005 Mercury Montego, 2005 Ford Freestyle, and 2005 Ford Five Hundred. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: To prevent damage to the generator, do not make the jumper wire connections except as directed.
CAUTION: Do not allow any metal object to come in contact with the housing and the internal diode cooling fins with the key ON or OFF. A short circuit may result and burn out the diodes.
NOTE: Battery posts and cable clamps must be clean and tight for accurate meter indications.
NOTE: Refer to the tester manual for complete directions for testing the charging system.
  1. Turn off all lamps and electrical components.
  2. Place the transmission in NEUTRAL and apply the parking brake.
  3. Carry out the following generator tests:
scientia non olet · About LEMON Manuals