LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.0 3, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 2629 (Exhaust System) >> Removal And Installation >> Exhaust Y-Pipe - 3.5L >> Removal and Installation

Removal and Installation

WARNING: This page is about a different car, the 2011 Mercury Milan, 2011 Lincoln MKZ, and 2011 Ford Fusion. However, it is still accessible from the selected car via links, so may be relevant.
    NOTE: Always install new fasteners and gaskets. Clean flange faces prior to new gasket installation to make sure of proper sealing.
  1. With the vehicle in NEUTRAL, position it on a hoist. For additional information, refer to JACKING & LIFTING article.
  2. If equipped, remove the 6 screws and the underbody shield.
    Fig 1: Locating Underbody Shield Screws
    G06269405Courtesy of FORD MOTOR CO.
  3. Remove and discard the 2 exhaust Y-pipe-to-resonator nuts.
    • Discard the gasket.
    • To install, tighten to 40 Nm (30 lb-ft).
  4. Remove and discard the 2 RH catalytic converter-to-exhaust Y-pipe nuts.
    • To install, tighten to 40 Nm (30 lb-ft).
  5. Remove and discard the 2 exhaust Y-pipe-to-LH catalytic converter nuts and remove the exhaust Y-pipe.
    • Discard the gasket.
    • To install, tighten to 40 Nm (30 lb-ft).
  6. To install, reverse the removal procedure.
    • Install new gaskets and nuts.
  7. Start the engine and check for exhaust leaks.