LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.0 3, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 252 (Starting System) >> System Tests >> Test B: Unusual Starter Noise

Test B: Unusual Starter Noise

WARNING: This page is about a different car, the 2004 Lincoln LS, 2004 Ford Thunderbird, 2003 Lincoln LS, and 2003 Ford Thunderbird. However, it is still accessible from the selected car via links, so may be relevant.
  1. Verify starter is installed properly. Ensure bolts are tight. Repair as necessary and check system for normal operation. If starter is mounted properly, go to next step.
  2. Connect remote starter switch between starter terminal "B" (Red wire) and starter motor terminal "S" (Gray wire). Engage starter motor and verify noise is coming from starter motor. If noise is coming from starter motor, go to next step. If noise is not coming from starter motor, diagnose engine mechanical concern. See appropriate article in ENGINES.
  3. Remove starter motor. See STARTER MOTOR  under REMOVAL & INSTALLATION. Inspect flywheel ring gear for wear or damage. If ring gear is okay, replace starter motor. If ring gear is worn or damaged, replace ring gear and inspect starter drive gear. If drive gear is also damaged, replace starter motor.
scientia non olet · About LEMON Manuals